______________________________________________________Chapter 5 - Troubleshooting, Page 5-3
Exhaust Fan
Symptom
Probable Cause
Corrective Action
1
If the
START FAN
button is pushed
but the exhaust
fan does not come
on.
A. Overload protector on the
magnetic starter has tripped.
1 Push the "Reset" button on the
magnetic starter and push the
START FAN
button.
B. If a HOA (Hands Off/Automatic)
type magnetic starter switch is
used, the selector switch may
have been moved from the
automatic position.
1 Check the switch and turn the
selector to the automatic
position.
C. Exhaust fan circuit breaker
tripped.
1 Re-set circuit breaker.
D. If the system is equipped with a
fused disconnect switch for the
exhaust fan, a fuse or fuses may
have blown out.
1 Check continuity of fuses and
replace if necessary.
E. The Gaylord Command Center
may have been improperly wired.
1 Refer to the wiring diagrams in
the Command Center Technical
Manual.
F. The Gaylord Command Center is
malfunctioning.
1 Refer to the Command Center
Technical Manual.
Poor Grease Extraction
Symptom
Probable Cause
Corrective Action
1 Poor grease
extraction.
A. Ventilators exhausting too much
air can cause an excessive
amount of noise and allow grease
to be pulled through the
extraction chamber. Ventilators
exhausting below design will also
allow grease to be pulled through
the extraction chamber.
1 Check for proper exhaust
volume by following the
instructions beginning on Page
6-1.
B. Sticky grease may have
accumulated within the
extraction chamber, creating a
higher velocity allowing grease to
be pulled through.
1 Open the Extractor Access Door
and inspect for grease
accumulation. If the Ventilator
is not being washed effectively
refer to the Troubleshooting
section on Wash System.
Table T-5-3-1
Table T-5-3-2
Содержание CG3-UVi-SPC Series
Страница 3: ...Page iii ...
Страница 6: ...Page vi This Page Intentionally Left Blank ...
Страница 136: ...Figure 8 1 1 Typical UVi and SPC Internal Wiring ...
Страница 157: ...Form TM CG3 UVi SPC Rev 04 0516 20934 Copyright 2016 Litho in USA ...