MANUAL PILOT FIREBOWL
Side Mounted Ignition
•
45
•
54
•
68 NL & LL Firebowl
MAINTENANCE
Properly maintained, your decorative gas ap-
pliance will provide years of useful service. A
regular routine maintenance program such as
the program outlined below should be estab-
lished and followed. It is further recommend
-
ed to follow the maintenance procedures on
safety valves and other accessory equipment
according to the manufacturers instructions.
It is recommended to have at least one annual
inspection performed by a certified gas tech-
nician.
Routine Preventive Maintenance:
Have the appliance serviced and leak checked
annually by a qualified service technician.
Keep the area inside and around the ap-
pliance and base free of debris, foreign
matter, or obstruction. Regularly remove all
broken rock chips, leaves, branches, grass, etc
from fire feature.
Clean any corrosion or scale off burner, con-
trol panel, and venturi with a wire brush.
Make sure that venturi remains set in position.
See page 18.
Visually inspect the burner annually both
while firing and while turned off. Replace any
corroded parts.
Visually inspect pilot while main burner is on
and while main burner is off. Replace any cor
-
roded parts. Be certain that pilot position is
correct and that pilot reliably and accurately
ignites main burner.
Use a tooth pick or thin wire to poke out any
clog or obstruction from the small holes in the
burner, ONLY WHEN BURNER IS OFF.
Check to be certain that the area the gas
equipment operates in is free of obstruction.
Remember, that for proper combustion, prop-
er operation, and proper ventilation, flow of
air around your gas equipment must be un-
obstructed. Never store combustible materials
or flammable liquids near any gas equipment.
When burners are not in use for a long time,
or are used only seasonally, care should be
taken to wire brush scale off burners and
inside venturi. An air compressor can be
used to blow out cobwebs or nests which may
clog orifices.
*If any unusual behavior of the gas equip-
ment is noted during inspection, shut the
burner off until qualified service assistance
can be obtained.
*For your safety, all repairs on the burner sys-
tem should be performed by qualified service
personnel only as it involves disconnecting gas
supply and performing leak testing.
Installation and repair should be done by
a qualified service person. The appliance
should be inspected before use and at least
annually by a qualified service person.
More frequent cleaning may be required
as necessary. It is imperative that the con-
trol compartment, burners, and circulating-
air passageways of the appliance are kept
clean.
MAINTENANCE
29
A.
B.
C.
D.
E.
F.
G.
H.
