MANUAL PILOT FIREBOWL
Side Mounted Ignition
•
45
•
54
•
68 NL & LL Firebowl
WARNINGS
12
FOR YOUR SAFETY READ BEFORE
OPERATING
!
FOR YOUR SAFETY READ BEFORE
OPERATING
!
FOR YOUR SAFETY READ BEFORE
OPERATING
!
FOR YOUR SAFETY READ BEFORE
OPERATING
!
WARNING: IF YOU DO NOT FOLLOW THESE INSTRUC-
TIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT
CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR
LOSS OF LIFE.
• IMPROPER INSTALLATION, ADJUSTMENT, ALTERA
-
TION, SERVICE OR MAINTENANCE CAN CAUSE INJURY
OR PROPERTY DAMAGE.
• INSTALLATION & GAS CONNECTION IS TO BE HARD
PIPE & MUST BE DONE BY A CERTIFIED GAS TECHNI
-
CIAN, QUALIFIED INSTALLER, SERVICE AGENCY OR GAS
SUPPLIER. FOR ASSISTANCE OR ADDITIONAL INFOR-
MATION CONSULT A QUALIFIED INSTALLER, SERVICE
AGENCY, OR THE GAS SUPPLIER.
• THIS APLIANCE IS A DECORATIVE GAS APPLIANCE FOR
OUTDOOR USE ONLY AND MUST NOT BE USED FOR COOK
-
ING.
COLOMBO CONSTRUCTION CORP disclaims any responsibility
for, and the warranty will be voided by the following actions:
• Installation & use of any damaged components.
• Modification of the burner and valve assemblies.
• Installation other than as instructed by this Owner’s Manual.
• Installation and/or use of any component part not approved
by Colombo Construction Corp.
ANY SUCH ACTION MAY CAUSE A FIRE HAZARD.
(See additional warranty info pg 6)
The installation of this appliance must conform with local
codes or, in the absence of local codes, with the National Fuel
Gas Code, ANSI Z223.1.
Solid fuels are not to be burned in this gas appliance.
The appliance should be inspected before each use for debris,
damage, or corrosion, and at least annually by a qualified ser-
vice person.
• INSPECT THE APPLIANCE & COMPONENTS.
• DO NOT INSTALL DAMAGED COMPONENTS.
• DO NOT INSTALL INCOMPLETE COMPONENTS.
• REPORT DAMAGED PARTS TO DEALER.
Do NOT use this appliance if any part has been under water.
Immediately call a qualified service technician to inspect the
appliance and to replace any part of the control system and any
gas control which has been under water.
More frequent cleaning may be required as necessary. It is im
-
perative that control compartment, burners and circulating air
passageways of the appliance be kept clean to provide for ad-
equate combustion and ventilation air.
This appliance is only for use with the type of gas indicated
on the rating plate. This appliance is not convertible for use
with other gases.
The appliance and its individual shut-off valve must be discon-
nected from the gas supply piping system during any pressure
testing of that system at test pressures in excess of ½ psi.
The appliance must be isolated from the gas supply piping sys-
tem by closing its individual manual shutoff valve during any
pressure testing of the gas supply piping system at test pres-
sures equal to or less than ½ psi.
A test gage connection shall be furnished downstream of the
gas appliance pressure regulator for measuring gas pressure.
The connection shall be a 1/8 inch NPT plug or cap with cleanly
cut tapered pipe threads in accordance with the Standard for
Pipe Threads, General Purpose (Inch), ANSI/ASME B1.20.1.
If the plug is of the slotted type it shall also incorporate square
or hex flats; or when the pressure test gage connection is pro-
vided as part of the control this pressure test gage connection
shall be:
(a) A tapping sealed by a 1/8 inch NPT plug or cap with cleanly
cut tapered pipe threads in accordance with the Standard for
Pipe Threads, General Purpose (Inch), ANSI/ASME B1.20.1.
If the plug is of the slotted type, it shall also incorporate square
or hex flats; or
(b) A hose fitting with a minimum length of 0.355 in (9.02
mm) and a 0.355 in (9.02 mm) maximum/0.335 in (8.05 mm)
minimum outside diameter and which incorporates a sealing
means.
The construction of the hose fitting shall incorporate an inter-
nal restriction not greater than 0.0394 in (1.0 mm) in diameter.
Children and adults should be alerted to the hazards of high
surface temperatures and should stay away to avoid burns or
clothing ignition. Young children should be carefully super
-
vised when they are in the area of the appliance.
Clothing or other flammable materials should not be hung
from the appliance, or placed on or near the appliance.
Any guard or other protective device removed for servicing the
appliance must be replaced prior to operating the appliance.
Use outside only in well ventilated area. Do not use inside house, camp
-
er, tent, garage, vehicle or any type of un-vented or enclosed area.
