Evoqua V10K, Руководство пользователя

Страница: 5 / 150

SP-1
WT.025.100.001.UA.IM.0614
V10K V-NOTCH CHLORINATOR
VERY IMPORTANT SAFETY PRECAUTIONS
This and the following page entitled “Very Important Safety Precautions” provide, in brief, information of urgent
importance relative to safety, installation, operation, and maintenance of this equipment.
WARNING
TO AVOID POSSIBLE SEVERE PERSONAL INJURY OR EQUIPMENT DAMAGE, OBSERVE THE FOLLOWING:
THIS EQUIPMENT SHOULD BE INSTALLED, OPERATED AND SERVICED ONLY BY TRAINED, QUALIFIED PERSONNEL
WHO ARE THOROUGHLY FAMILIAR WITH THE ENTIRE CONTENTS OF THIS INSTRUCTION BOOK.
HAZARDOUS GAS IS PRESENT IN THIS EQUIPMENT DURING NORMAL OPERATION. TO AVOID POSSIBLE SEVERE
PERSONAL INJURY OR DAMAGE TO THE EQUIPMENT, READ THIS INSTRUCTION BOOK AND THE APPROPRI-
ATE GAS MANUAL BEFORE CONNECTING THIS EQUIPMENT TO VACUUM A SUPPLY OF GAS. OPERATION AND
MAINTENANCE OF THIS EQUIPMENT MUST BE RESTRICTED TO TRAINED, QUALIFIED PERSONNEL WHO ARE
COMPLETELY FAMILIAR WITH THESE INSTRUCTIONS.
TURN OFF THE GAS SUPPLY AT THE CONTAINER VALVE, WAIT UNTIL THE SUPPLY VACUUM GAUGE READS FULL
SCALE AND THE ROTAMETER FLOAT RESTS ON THE BOTTOM STOP, AND THEN TURN OFF THE INJECTOR WATER
SUPPLY BEFORE PERFORMING ANY DISASSEMBLY OPERATIONS FOR TROUBLESHOOTING PURPOSES.
DO NOT OPEN THE GAS SUPPLY CONTAINER VALVE MORE THAN ONE COMPLETE TURN. THIS WILL PERMIT
MAXIMUM DISCHARGE AND CAN ALSO BE TURNED OFF QUICKLY IN CASE OF A GAS LEAK.
THE GAS CONTROL UNIT MUST BE CONNECTED TO A VACUUM GAS SUPPLY ONLY. DO NOT OPEN THE CYLIN-
DER OR DRUM VALVE UNTIL THE SYSTEM HAS BEEN FULLY INSTALLED AND THE PRE-START CHECKS HAVE BEEN
CARRIED OUT.
ESCAPED GAS MUST BE EXHAUSTED TO OUTSIDE ATMOSPHERE. THE EXHAUST SYSTEM MUST TERMINATE IN AN
AREA WHERE GAS FUMES CANNOT CAUSE INJURY TO PERSONNEL OR PROPERTY DAMAGE. DO NOT TERMINATE
THE EXHAUST SYSTEM AT A LOCATION ROUTINELY USED BY PERSONNEL, SUCH AS WORK AREAS OR PATHWAYS
NOR NEAR WINDOWS OR VENTILATION SYSTEM INTAKES.
ALL CLEANING SHOULD BE CARRIED OUT IN AN OPEN AREA OR IN A WELL VENTILATED ROOM.
DO NOT USE WOOD ALCOHOL, ETHER, PETROL OR PETROLEUM DISTILLATES.
DO NOT USE HYDROCARBONS OR ALCOHOLS BECAUSE RESIDUAL SOLVENT MAY REACT WITH THE GAS. SOL-
VENTS CAN PRODUCE SERIOUS PHYSIOLOGICAL EFFECTS UNLESS USED IN STRICTEST COMPLIANCE WITH THE
SOLVENT MANUFACTURER’S SAFETY RECOMMENDATIONS.
WHEN USING HYDROCHLORIC ACID, OBSERVE ALL SAFETY PRECAUTIONS RECOMMENDED BY THE ACID MANU-
FACTURER/SUPPLIER.
EVOQUA W3T109612