E-Z-GO FLEET 1999, Руководство по ремонту и обслуживанию техника

Страница: 13 / 188

I
GENERAL INFORMATION & ROUTINE MAINTENANCE
I
A
Read all of Section Band this section before attempting any procedure. Pay particular attention to all Notes, Cautions and Warnings
SERIAL NUMBER PLATE LOCATION
The serial and manufacturing numbers are stamped on a
plate on the passenger side of the dash panel (Ref Fig. 1
on page A-1 ).
Design changes take place on an ongoing basis. In order
to obtain correct components for the vehicle, the manu­
facturing date and serial number must be provided when
ordering service parts.
Fig. 1 Serial Number Plate Location
STARTING THE VEHICLE WITH A
DISCHARGED BATTERY
A
WARNING.A.
Do not attempt to 'jump
start' a vehicle using
another vehicle.
The vehicle is equipped with a starter/generator. When
starting the engine, the starter/generator functions as a
starter and with the engine running, it functions as a gen­
erator.
With the running times associated with this kind of vehi­
cle, the generator is more than adequate to maintain the
battery charge level. The generator is not designed to
charge a discharged battery.
Since the engine stops when the accelerator is released,
jump starting should not be attempted.
If the vehicle is equipped with lights and/or accessories
that are used when the vehicle is not in motion, the
starter/generator may not be adequate to maintain bat­
tery charge. In this situation, the battery may require
charging with a 12V 1 0 amp max charger.
Observe all instructions provided by the manufacturer of
the charger.
FUEL
The fuel tank is located under the seat, on the passenger
side of the vehicle (Ref Fig. 2 on page A-1). Fill tank with
fresh, clean, automotive grade, unleaded, 87 octane
(minimum) gasoline. Heavy use/load applications may
benefit from higher octane gasoline.
CAUTION
Do not over fill the fuel tank. Allow ade­
quate space for the expansion of gaso­
line. Leave at least 1" (2.5 cm) space below bottom of filler neck.
Fig. 2 Fuel Tank
.A_ WARNING.A_
could result in fuel spillage.
When refueling, inspect
the fuel tank cap for
leaks or breaks that
To prevent a possible explosion, do not smoke near
the fuel tank or refuel near open fire or electrical
items which could produce a spark.
Always wear safety glasses while refueling to prevent
possible injury from gasoline or gasoline vapor.
Do not handle fuel in an area that is not adequately
ventilated. Do not permit anyone to smoke in an area
where vehicles are being fueled.
Repair and Service Manual
Page A-1