Doosan GV158TIC, Руководство по эксплуатации и техническому обслуживанию

Страница: 9 / 162

Safety Regulations & Engine Specifications - 3 -
1.2.3. During commissioning, starting and operation
●
This is the safety alert symbol. When you see this symbol in this manual, be alert to the potential for
personal injury.
●
Carefully read all safety message in this manual and on your safety signs. Be sure new equipment
components and repair parts include the current safety signs.
●
Avoid possible injury or death from runaway. Do not start engine by shorting across starter termi-
nals.
●
Prevent fires by keeping machine clean of accumulated trash, grease, fuel and debris.
●
When the engine is running, do not get too close to the rotating parts.
●
Do not touch the engine with bare hands when it is warm from operation risk of bums.
●
Exhaust gases are toxic. If it is necessary to run an engine in an enclosed area, remove the exhaust
gases from the area with an exhaust pipe extension. If you do not have an exhaust pipe extension,
open the doors and get outside air into the area.
●
Keep vicinity of engine free of oil and grease. Accidents caused by slipping can have serious conse-
quences.
1.2.4. During maintenance and care
●
Always carry out maintenance work when the engine is switched off. If the engine has to be main-
tained while it is running, e.g. changing the elements of change-over filters, remember that there is a
risk of scalding. Do not get too close to rotating parts.
●
Change the oil when the engine is warm from operation.
Caution:
There is a rise of burns and scalding. Do not touch oil drain plug or oil filters with bare hands.
●
Take into account the amount of oil in the sump. Use a vessel of sufficient size to ensure that the oil
will not overflow.
●
Open the coolant circuit only when the engine has cooled down. If opening while the engine is still
warm is unavoidable, comply with the instructions in the chapter "Maintenance and Care".
●
Neither tighten up nor open pipes and hoses (lube oil circuit, coolant circuit and any additional
hydraulic oil circuit) during the operation. The fluids which flow out can cause injury.
●
Fuel is inflammable. Do not smoke or use naked lights in its vicinity. The tank must be filled only
when the engine is switched off.
●
When using compressed air, e.g. for cleaning the radiator, wear goggles.
●
Keep service products (anti-freeze) only in containers which can not be confused with drinks con-
tainers.
●
Comply with the manufacturer's instructions when handling batteries.
Caution:
Accumulator acid is toxic and caustic. Battery gases are explosive.