COE ORCHARD EQUIPMENT INC R Series, Руководство пользователя

Страница: 23 / 48

S ervice
20
WATER TANK
Fill water tank DAILY or more often depending upon working
conditions. Use 1 1/2 to 2 quarts of COE SLING LUBE per tank refill. Take care
not to allow debris in water tank when filling
HYDRAULIC OIL RESERVOIR/FILTER
ALWAYS keep reservoir filled to
proper level with clean oil. Fill to center of site glass on riser. DO NOT over fill or
overflow will occur at operating temperature.
RADIATOR COOLANT
Check & fill by coolant bottle. NEVER check radiator
coolant when hot. Use a mixture of 50% water 50% high quality coolant.
DIESEL RESERVOIR
Fill diesel reservoir daily to prevent running out of fuel
while operating. DO NOT smoke while refueling and stay away from flame and
sparks. USE filtered high quality diesel fuel. Ultra Low Sulfur fuel required
ENGINE OIL ALWAYS check engine oil level daily. Remove dip stick wipe
clean, reinstall and remove for proper oil level. If below level mark fill with high
quality 15-40w motor oil.
AIR CLEANER
Clean air cleaner DAILY or MORE OFTEN in severe dust con-
ditions. When cleaning check SAFETY element for any signs of dust that may
indicate faults in the PRIMARY air cleaner. INSPECT air cleaner ducting regular-
ly to for loose clamp, holes, or cracks. This can help prevent a dusted motor.
BATTERY
It is recommended to remove battery during off season storage.
Check for any damage, check water level and store on trickle charger. If battery
is BAD dispose of it properly and replace it.
GEAR OIL Inspect gear hub oil level prior to first operation of the season.
To check oil level place plug to middle of hub. Proper hub level should be 1/2
full. Add if necessary. Over filling hub may cause seal to go out.
ECU
The ECUs are located in a single area by opening an access door on the
rear fender. NEVER weld on machine without disconnecting ECU first. DO NOT
use high pressure water in this area.
Service point descriptions
DANGER! DO NOT WELD ON MACHINE WITHOUT
DISCONNECTING ECU ’ s FIRST. DAMAGE WILL OCCUR!
WARNING! WHEN WASHING DOWN EQUIPMENT DO NOT USE HIGH PRESSURE
WATER NEAR ELECTRICAL COMPONENTS LIKE ECU, DISPLAY, FOOT PEDALS,
WIRING OR WIRING HARNESS CONNECTIONS. DAMAGE MAY OCCUR
!