Alliance Laundry Systems LTS97A*N, Руководство по обслуживанию

Страница: 3 / 126

801803
1
© Copyright 2004, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without
the expressed written consent of the publisher.
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
Table of Contents
Model Identification ................................................3
Section 1 – Safety Information
Locating an Authorized Servicer ............................6
Section 2 – Introduction
Customer Service ....................................................7
Nameplate Location ................................................7
How Your Stacked Washer/Dryer Works ...............8
Section 3 – Troubleshooting
1. Washer Motor Circuit ....................................11
Dryer
2. Dryer Motor Does Not Run ...........................13
3. Dryer Stops In Cycle; Quits After The First Few
Loads; Has A Burning Smell; Cycles On Motor
Thermal Protector .........................................14
4. Dryer Motor Runs But Cylinder
Does Not Turn ...............................................15
5. Dryer Motor Does Not Stop ..........................15
6. Dryer Runs Only When Door is Open ...........16
7. Dryer Heating Assembly Does Not Heat or
Burner Does Not Ignite .................................16
8. Igniter Does Not Glow (Gas Supply Sufficient)
– Gas Dryer Models .......................................17
9. Burner Ignites And Goes Out Repeatedly – Gas
Dryer Models .................................................17
10. Igniter Glows But Burner Does Not Ignite – Gas
Dryer Models .................................................17
11. Dryer Heater Assembly Or Burner Shuts Off
Prematurely ....................................................18
12. Dryer Heater Assembly or Burner Repeatedly
Cycles Off On Limit Thermostat ...................18
13. Dryer Heater Assembly or Burner Does Not
Shut Off ..........................................................19
14. Clothes Do Not Dry in Dryer .........................19
15. Timer Does Not Advance In
Automatic Cycle ............................................20
16. Clothes Are Too Hot When Removed From
Dryer ..............................................................21
17. Excessive Chattering Or Vibrating Noise in
Dryer ..............................................................21
18. Excessive Humming Or Whistling Noise in
Dryer ..............................................................21
Washer Control
19. Washer Error Code Listing ............................23
20. Washer Will Not Start – No LEDs/Lights lit
(No response to start switch) ..........................24
21. Washer Will Not Start – Door Open Error
(Wash/Rinse LEDs Flashing – Door must be
closed and attempting to lock) .......................26
22. Washer Will Not Start – No Door Lock
(Door LED Flashing) .....................................28
23. Washer Motor Will Not Run
(Door/Final Spin LEDs Flashing) ..................30
24. Washer Will Not Fill – No Communication
Error (Wash/Door LEDs Flashing) ................32
25. Washer Overflows .........................................34
26. Pump Does Not Operate ................................36
27. Serial Communication Error
(Final Spin/Rinse LEDs Flashing) .................38
Section 4 – Grounding
28. Wall Receptacle Polarity Check (Washer Power
Cord) ..............................................................41
29. Ground Wires From Power Cord To Rear
Bulkhead And From Rear Bulkhead To Control
Cabinet Check Wall Receptacle Polarity (Gas
Dryer Models Only) .......................................42
30. Ground Wire From Terminal Block To Rear
Bulkhead and From Rear Bulkhead To Control
Cabinet (Electric Dryer Models Only) ...........43
31. Washer Ground Connections .........................44
32. Dryer Ground Connections ............................46
Section 5 – Service Procedures
33. To Remove the Dryer .....................................49
34. Control Panel and Controls ............................50
35. Washer Control ..............................................52
36. Pressure Switch ..............................................53
37. Control Cabinet ..............................................53
38. Washer Lower Access Panel ..........................53
39. Inverter Control ..............................................54
40. Electric Drain Pump .......................................55
41. Washer Belt ....................................................56
42. Mixing Valve .................................................57
43. Washer Front Panel ........................................58
(continued)