Aircel DHT-100, Инструкция по установке и эксплуатации

Страница: 27 / 36

High Inlet Temperature Refrigerated Air Dryer
27
NON-FLAMMABLE GAS MIXTURE MSDS - 50040 EFFECTIVE DATE: APRIL 19, 2005
PAGE 3 OF 5
8. EXPOSURE CONTROLS - PERSONAL PROTECTION
VENTILATION AND ENGINEERING CONTROLS : No special ventilation systems or engineering controls are needed under normal
circumstances of use. As with all chemicals, use this gas mixture in well-ventilated areas. If this gas mixture is used in a poorly-ventilated area,
install automatic monitoring equipment to detect the levels of Phosphine and Oxygen.
RESPIRATORY PROTECTION : No special respiratory protection is required under normal circumstances of use. Maintain Phosphine levels below
50% of the TLV (TLV = 0.3 ppm) and oxygen levels above 19.5% in the workplace. Use supplied air respiratory protection when Phosphine levels
exceed 50% of the TLV (TLV = 0.3 ppm), oxygen levels are below 19.5%, or during emergency response to a release of this gas mixture. During
an emergency situation, before entering the area, check the concentration of Phosphine and Oxygen. If respiratory protection is required, follow the
requirements of the Federal OSHA Respiratory Protection Standard (29 CFR 1910.134), or equivalent State standards.
EYE PROTECTION : Safety glasses. If necessary, refer to U.S. OSHA 29 CFR 1910.133 or appropriate Canadian Standards.
HAND PROTECTION : Wear leather gloves when handling cylinders. Chemically resistant gloves should be worn when using this gas mixture. If
necessary, refer to U.S. OSHA 29 CFR 1910.138 or appropriate Standards of Canada.
BODY PROTECTION : No special protection is needed under normal circumstances of use. If a hazard of injury to the feet exists due to falling
objects, rolling objects, where objects may pierce the soles of the feet or where employee’s feet may be exposed to electrical hazards, use foot
protection, as described in U.S. OSHA 29 CFR 1910.136.
9. PHYSICAL and CHEMICAL PROPERTIES
The following information is for Nitrogen, the main component of this gas mixture.
GAS DENSITY @ 32°F (0 ° C) and 1 atm: .072 lbs/ ft
3
(1.153 kg/m
3
)
FREEZING/MELTING POINT @ 10 psig: -345.8°F (-210°C) BOILING POINT : -320.4°F (-195.8°C)
SPECIFIC GRAVITY (air = 1) @ 70°F (21.1°C): 0.906 pH : Not applicable.
SOLUBILITY IN WATER vol/vol @ 32°F (0 ° C) and 1 atm: 0.023 MOLECULAR WEIGHT: 28.01
EVAPORATION RATE (nBuAc = 1): Not applicable. EXPANSION RATIO: Not applicable.
VAPOR PRESSURE @ 70°F (21.1°C) (psig) : Not applicable. SPECIFIC VOLUME (ft
3
/lb) : 13.8
COEFFICIENT WATER/OIL DISTRIBUTION : Not applicable.
The following information is for Air, a balance gas:
The following information is for Air, a balance gas:
BOILING POINT : -317.8 ° F (-194.3 ° C) FREEZING/MELTING POINT (@ 10 psig: -216.2 ° C (-357.2 ° F)
SOLUBILITY IN WATER Vol/Vol at 0 ° C (32 ° F) : 0.0292 MOLECULAR WEIGHT: 28.975
SPECIFIC GRAVITY (air = 1) @ 70°F (21.1°C): 1 pH : Not applicable.
EVAPORATION RATE (nBuAc = 1):
Not applicable.
EXPANSION RATIO
: Not applicable.
ODOR THRESHOLD : Not applicable. SPECIFIC VOLUME (ft
3
/lb) : Not applicable for Air; 13.8 (for Nitrogen)
VAPOR PRESSURE @ 21.1°c; 70°F (psig) : Not applicable. COEFFICIENT WATER/OIL DISTRIBUTION : Not applicable.
The following information is for the gas mixture:
APPEARANCE AND COLOR : This gas mixture is a colorless, odorless gas.
HOW TO DETECT THIS SUBSTANCE (warning properties): In terms of leak detection, fittings and joints can be painted with a soap solution
to detect leaks, which will be indicated by a bubble formation.
10. STABILITY and REACTIVITY
STABILITY : Normally stable in gaseous state.
DECOMPOSITION PRODUCTS : Due to components of this gas mixture (1,1,2-Trichloro-1,1,2-trifluoroethane, Tetrafluoromethane,
Trichlorofluoromethane, and Dichlorodifluoromethane), if exposed to fire, this gas mixture may decompose yielding toxic products (i.e. hydrogen
fluoride, phosgene, hydrogen chloride, carbonyl fluoride). The other components of this gas mixture do not decompose, per se, but can react with
other compounds in the heat of a fire.
MATERIALS WITH WHICH SUBSTANCE IS INCOMPATIBLE : Titanium will burn in Nitrogen (a main component of this gas mixture). Lithium
reacts slowly with Nitrogen at ambient temperatures. Components of this gas mixture (1,1,2-Trichloro-1,1,2-trifluoroethane, Tetrafluoromethane,
Trichlorofluoromethane, and Dichlorodifluoromethane) are incompatible with sodium, potassium, calcium, zinc, and magnesium, powdered
aluminum, and alloys of these metals.
HAZARDOUS POLYMERIZATION : Will not occur.
CONDITIONS TO AVOID : Contact with incompatible materials. Cylinders exposed to high temperatures or direct flame can rupture or burst.
11. TOXICOLOGICAL INFORMATION
TOXICITY DATA : The following toxicology data are available for the components of this gas mixture:
DICHLORODIFLUOROMETHANE:
LC (Inhalation-rat) > 80 pph/4 hours
LC
50
(Inhalation-mouse) 3348 gm/m
3
/3
hours: Behavioral: sleep, tremor,
excitement
LC
50
(Inhalation-rabbit) 80 pph/30 minutes
LC
50
(Inhalation-guinea pig) 80 pph/30
minutes
TCLo (Inhalation-Human) 200000 ppm/30
minutes: conjunctive, fibrosing
alveolitis, liver changes
TCLo (Inhalation-rat) 4136 mg/m
3
/8
hours/6 weeks-intermittent: chronic
pulmonary edema; Related to Chronic
Data: death
TCLo (Inhalation-rat) 3997 mg/m
3
/90 days-
continuous: Lungs, Thorax, or
Respiration: chronic pulmonary
edema; death
TCLo (Inhalation-monkey) 3997 mg/m
3
/90
days-continuous: Lungs, Thorax, or
Respiration: chronic pulmonary edema
TCLo (Inhalation-rabbit) 3997 mg/m
3
/90
days-continuous: Lungs, Thorax, or
Respiration: chronic pulmonary edema
TCLo (Inhalation-guinea pig) 3997
mg/m
3
/90 days-continuous: Lungs,
Thorax, or Respiration: chronic
pulmonary edema; Liver: hepatitis
(hepatocellular necrosis), diffuse;
Related to Chronic Data: death
LD (Oral-rat) > 5600 µ g/kg
TDLo (Oral-rat) 2548 mg/kg/26 weeks-
intermittent: Behavioral: alteration of
classical conditioning; Blood: changes
in erythrocyte (RBC) count;
Biochemical: Enzyme inhibition,
induction, or change in blood or tissue
levels: true cholinesterase
1,1,1,2-TETRAFLUOROETHANE:
LC
50
(Inhalation-Rat) 1500 gm/m
3
/4 hours
LC
50
(Inhalation-Mouse) 1700 gm/m
3
/2
hours
LC (Inhalation-Dog) > 32 pph/1 hour
TCLo (Inhalation-Rat) 50,000 ppm/6 hours/2
years-intermittent: Tumorigenic:
neoplastic by RTECS criteria;
Endocrine: tumors
TCLo (Inhalation-Rat) 30 pph/6 hours:
female 6-15 day(s) after conception:
Reproductive: Maternal Effects: other
effects; Effects on Embryo or Fetus:
fetotoxicity (except death, e.g., stunted
fetus)
TRICHLOROFLUOROMETHANE:
TCLo (Inhalation-Human) 50,000 ppm/30
minutes: Sense Organs and Special
Senses (Eye):conjunctive irritation;
Lungs, Thorax, or Respiration: fibrosing
aleveolitis; Liver: other changes
LD (Oral-Rat) > 352 mg/kg
LD
50
(Intraperitoneal-Mouse) 1743 mg/kg:
Behavioral: convulsions or effect on
seizure threshold
LC
50
(Inhalation-Rat) 13 pph/15 minutes:
Behavioral: tremor, convulsions or effect
on seizure threshold; Lungs, Thorax, or
Respiration: respiratory depression
LC
50
(Inhalation-Mouse) 10 pph/30 minutes
LC
50
(Inhalation-Rabbit) 25 pph/30
LC
50
(Inhalation-Guinea Pig) 25 pph/30
minutes
TCLo (Inhalation-Rat) 12,000 ppm/4
hours/days-intermittent: Brain and
Coverings: other degenerative changes;
Lungs, Thorax, or Respiration: chronic
pulmonary edema
1,1,2-TRICHLORO-1,1,2-
TRIFLUOROETHANE:
TCLo (Inhalation-Human) 4300 mg/m
3
/5
Days-intermittent: Brain and Coverings:
recordings from specific areas of CNS
TCLo (Inhalation-Human) 178 mg/m
3
/10
years-intermittent: Behavioral:
headache
Open Irritation Test (Skin-Rabbit) 500 mg:
Mild
Standard Draize Test (Skin-Rabbit) 500
mg/24 hours: Mild
LD
50
(Oral-Rat) 43 gm/kg: Behavioral:
somnolence (general depressed
activity); Gastrointestinal: other
changes; Skin and Appendages: hair
LD
50
(Intravenous-Mouse) 9 gm/kg:
Autonomic Nervous System: other
(direct) para-sympathomimetic;
Behavioral: altered sleep time (including
change in righting reflex); Skin and
Appendages: dermatitis, other (after
systemic exposure)
LD
50
(Unreported-Mouse) 40 gm/kg
LDLo (Oral-Rabbit) 17 gm/kg
LC
50
(Inhalation-Rat) 38,500 ppm/4 hours:
Behavioral: general anesthetic,
excitement, ataxia