3225-00
60706-241
CAUTION
FOLLOW THE INSTRUCTIONS IN THE OWNER’S MANUAL SPECIFICALLY WHEN PUTTING THIS PTO GENERATOR INTO
SERVICE.
IMPORTANT
ALL STANDBY POWER PLANTS INCLUDING TRACTOR DRIVEN GENERATORS SHOULD BE PERIODICALLY EXER-
CISED. FOR PROPER MAINTENANCE OF YOUR TRACTOR DRIVEN GENERATOR, IT SHOULD BE OPERATED FOR ONE
HOUR CARRYING RATED LOAD AT LEAST TWICE A YEAR. THIS WILL ASSURE THAT YOUR PTO GENERATOR IS IN
OPERATING CONDITION AND READY FOR USE WHEN THE NEED ARISES.
PARTS LIST, PARTS DRAWINGS, AND WIRING DIAGRAM PERTAINING TO YOUR UNIT ARE ENCLOSED WITH THIS
MANUAL.
TABLE OF CONTENTS
SAFETY INFORMATION
3
SPECIFICATIONS
4
UNPACKING
4
INSTALLATION
4
FOUNDATION MOUNTING
4
TRAILER MOUNTING
5
THREE POINT HITCH MOUNTING
5
ELECTRICAL CONNECTIONS
6
LOAD DISCONNECT PLUG INSTALLATION
7
PRE-START CHECKLIST
7
GENERATOR STARTING PROCEDURE
8
PTO ALIGNMENT
8
STORAGE & MAINTENANCE REQUIREMENTS
9
LUBRICATION
9
SERVICE DIAGNOSIS
10
COMPLETE UNIT ASSEMBLY ILLUSTRATION
11
WIRING DIAGRAM
12
RECEPTACLE PANEL ASSEMBLY
14
TWO WHEEL TRANSPORT
15
WINCO LIMITED WARRANTY
16
This manual covers the latest compact portable tractor driven Power Take Off (PTO) generator model from Winco.
This 10,000 watt generator is designed to provide120/240V single phase electrical power for standby and utility ser-
vice when commercial power is interrupted, inaccessible or impractical. This PTO unit has a cast iron gear case with
a 1-3/8” – 6 spline, 540 rpm rated input shaft (unit operating speed is 515 RPM) and brushless, heavy-duty 3600
rpm, 2 pole, low waveform distortion generator.
This compact PTO generator unit is designed to provide reliable electrical power for customers who already have a
compact utility tractor with 20 to 30 horsepower and a 540 rpm rated PTO shaft. The PTO unit is a cost-effective way
of providing needed electrical power without the cost or added maintenance of a dedicated drive engine. Primary ap-
plications for these PTOs are for infrequent or medium duty loads where the unit will normally be operated less than
50 to100 hours per year. Typical uses might be for farm, ranch or home standby or portable field power away from
convenient utility or where running an extension cord is impractical. The compact PTO units are built to last, but are
not intended for prime power (continuous or sole source) applications.
Copy you model and serial number here.
No other Winco generator has the same serial number
as yours. It is important that you record the number
and other vital information here. If you should ever
need to contact us about this unit it will help us to
respond to your needs faster.
MODEL ______________________________________
SERIAL NUMBER _____________________________
PURCHASE DATE _____________________________
DEALER _____________________________________
