2 7
2 6
Fuel
While refuelling, use only clean, fresh diesel fuel. Filter diesel fuel before
refuelling using silk or let it stand for 24 hours. Do not allow dust, dirt, debris or
water to fall into the fuel and into the fuel tank.
Diesel fuel level in the fuel tank should be checked before starting the
engine of generator. If the engine has just stopped, wait for 4-5 minutes or
more, so that the engine cools down, and only then start the refuelling.
Refuelling should be done only in the way when an airbag remains in the fuel
tank for the possible expansion of the fuel vapor when it is heating. The
maximum fuel level should be 2-3 cm below the lower edge of the filler neck of
the fuel tank.
Fuel filter
Both models are equipped with a fuel filter that allows the selection of fuel
solids and the separation of relatively large mechanical particles and water by
settling them.
A clogged fuel filter can be the cause of difficult engine start, of losing its
power, incorrect operating. In addition, dirty fuel filter can significantly reduce
the life of the engine.
Air filter
There is an air filter with a dry filter element on the engine power, which
condition should be checked before each engine's launch. It is strongly
recommended to check the air filter and change it according to the regulations
(see section 6 of this manual, "Maintenance").
A clogged air filter can be the cause of difficult engine start, of losing its
power, incorrect operating. In addition, dirty air filter can significantly reduce
the life of the engine.
5.3. GENETATOR’S OPERATION
NOTE
!
The device is sold without fuel in the fuel tank. Before each
use fill the fuel tank with diesel fuel.
NOTE
!
Fuel filter of the ERS 4.6d model is installed inside the fuel
tank.
WARNING
!
Refuelling should be done only when the engine doesn't
operating!
WARNING
!
Oil and fuel mustn't have contact with paper filter elements.
WARNING
!
It is forbidden to launch the engine of generator without the
air filter or the filter with unclosed fuel valve.
WARNING
!
Before the exploitation of the device, please, make the
engine breaking-in. Details, see the section below.
