%
%$77(5,(6$1'&+$5*,1*
Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
Repair and Service Manual
699326
NOTICE: The watering device should only be used if
the electrolyte level is less than 1/2" (13 mm) above
top of plates.
&OHDQLQJ%DWWHULHV
:KHQFOHDQLQJWKHRXWVLGHRIWKHEDWWHULHVDQGWHUPLQDOV
GRQRWXVHDZDWHUKRVHZLWKRXWILUVWVSUD\LQJZLWKDVROX
WLRQRIVRGLXPELFDUERQDWHEDNLQJVRGDDQGZDWHUWR
QHXWUDOL]HDQ\DFLGGHSRVLWV
8VHRIDZDWHUKRVHZLWKRXWILUVWQHXWUDOL]LQJDQ\DFLGZLOO
PRYHDFLGIURPWKHWRSRIWKHEDWWHULHVWRDQRWKHUDUHDRI
WKHYHKLFOHRUVWRUDJHIDFLOLW\ZKHUHLWZLOODWWDFNWKHPHWDO
VWUXFWXUHRUWKHFRQFUHWHDVSKDOWIORRU$IWHUKRVLQJGRZQ
WKHEDWWHULHVDUHVLGXHZLOOEHOHIWRQWKHEDWWHULHVZKLFK
LVFRQGXFWLYHDQGZLOOFRQWULEXWHWRWKHGLVFKDUJHRIWKH
EDWWHULHV
To decrease the risk of battery
damage, be sure that all battery
caps are tightly installed.
7KHFRUUHFWFOHDQLQJWHFKQLTXHLVWRVSUD\WKHWRSDQG
VLGHVRIWKHEDWWHULHVZLWKDVROXWLRQRIVRGLXPELFDUERQ
DWHEDNLQJVRGDDQGZDWHU7KLVVROXWLRQLVEHVWDSSOLHG
ZLWKDJDUGHQW\SHVSUD\HUHTXLSSHGZLWKDQRQPHWDOOLF
VSUD\ZDQG7KHVROXWLRQVKRXOGFRQVLVWRIFXS
PORIVRGLXPELFDUERQDWHEDNLQJVRGDPL[HGZLWK
JDOORQVOLWHUVRIFOHDUZDWHU)LJXUH,QDGGLWLRQWR
WKHEDWWHULHVVSHFLDODWWHQWLRQVKRXOGEHSDLGWRPHWDOOLF
FRPSRQHQWVDGMDFHQWWRWKHEDWWHULHVZKLFKVKRXOGDOVR
EHVSUD\HGZLWKWKHVRGLXPELFDUERQDWHEDNLQJVRGD
VROXWLRQ
)LJXUH3UHSDULQJ$FLG1HXWUDOL]LQJ6ROXWLRQ
$OORZWKHVROXWLRQWRVLWIRUDWOHDVWWKUHHPLQXWHVXVHD
VRIWEULVWOHEUXVKRUFORWKWRZLSHWKHWRSVRIWKHEDWWHULHV
WRUHPRYHDQ\UHVLGXHWKDWFRXOGFDXVHWKHVHOIGLVFKDUJH
RIWKHEDWWHU\5LQVHWKHHQWLUHDUHDZLWKORZSUHVVXUH
FOHDUZDWHU$OORIWKHLWHPVUHTXLUHGIRUFRPSOHWHEDWWHU\
FOHDQLQJDQGZDWHULQJDUHLQFOXGHGLQWKH%DWWHU\0DLQWH
QDQFH.LW31*
&OHDQEDWWHULHVRQFHDPRQWKRUPRUHRIWHQXQGHU
H[WUHPHFRQGLWLRQV
%DWWHU\5HPRYDODQG,QVWDOODWLRQ
7RRO/LVW
4XDQWLW\
,QVXODWHG:UHQFK´
6RFNHW´
5DWFKHW
%DWWHU\&DUULHU
7RUTXH:UHQFKLQOEV
7RUTXH:UHQFKIWOEV
NOTICE: Hardware that is removed must always be
installed in its original position unless otherwise
specified. If torque values are not specified, refer to
the Torque Specifications table in the GENERAL
INFORMATION AND ROUTINE MAINTENANCE sec-
tion.
Before any electrical service is
performed, the run/tow switch
must be placed in the TOW posi-
tion.
If a power wire (battery, motor or controller) is dis-
connected for any reason, the run/tow switch must
be left in the TOW position for at least 30 seconds
after the circuit is restored.
5HPRYHEDWWHU\KROGGRZQVDQGFDEOHV/LIWRXWEDWWHULHV
ZLWKDFRPPHUFLDOO\DYDLODEOHOLIWLQJGHYLFH
,IWKHEDWWHULHVKDYHEHHQFOHDQHGDQGDQ\DFLGLQWKH
EDWWHU\UDFNDUHDQHXWUDOL]HGDVUHFRPPHQGHGQRFRUUR
VLRQWRWKHEDWWHU\UDFNVRUVXUURXQGLQJDUHDVKRXOGEH
SUHVHQW$Q\FRUURVLRQIRXQGVKRXOGEHLPPHGLDWHO\
UHPRYHGZLWKDSXWW\NQLIHDQGDZLUHEUXVK7KHDUHD
VKRXOGEHZDVKHGZLWKDVROXWLRQRIVRGLXPELFDUERQDWH
EDNLQJVRGDDQGZDWHUWKRURXJKO\GULHGDQGWKHQ
SULPHGSDLQWHGZLWKDFRUURVLRQUHVLVWDQWSDLQW
7KHEDWWHULHVVKRXOGEHSODFHGLQWRWKHEDWWHU\UDFNVDQG
WKHEDWWHU\KROGGRZQVWLJKWHQHGWRWRUTXHVSHFLILHG
EHORZWLJKWHQRXJKWRGHFUHDVHWKHULVNRIPRYHPHQWEXW
QRWWLJKWHQRXJKWRGLVWRUWEDWWHU\FDVHV
1-1/2 Gal. (6 L) Water
Non-Metalic Wand
1/4 Cup (60 ML)
Baking Soda
2 Gal. (8 L)
Garden Sprayer
(1-1/2 Gal. (6 L)
Baking Soda Solution
,WHP
7RUTXH6SHFLILFDWLRQ
%DWWHU\+ROGGRZQ
1XW
LQOEV1P
