16
FAULT FINDING
Turn gas off at source and turn burner control knobs
1
.
to ‘OFF’. Wait at least five (5) minutes for gas to clear,
then retry.
If your barbecue still fails to light, check gas supply
2
.
and connections.
Repeat lighting procedure. If your barbecue still fails
3
.
to operate, turn the gas off at source, turn the control
knobs to‘OFF’, then check the following:
Obstruction in gas line
•
Correction: Remove fuel line from barbecue. Do
not smoke! Open gas supply for one second to
clear any obstruction from fuel line. Close off
gas supply at source and reconnect fuel line to
barbecue.
Plugged orifice
•
Correction:Remove burners from barbecue
.
Carefully lift each burner up and away from gas
valve orifice. Remove the orifice from gas valve
and gently clear any obstruction with a fine wire.
Then reinstall all orifices, burners, and cooking
components. If an obstruction is suspected in gas
valves or manifold contact your place of purchase
or service agent.
Disconnected electronic wires
•
correction: Inspect the igniter junction box found
behind the control panel. Connect losse electronic
wires to junction box and try to light the barbecue.
Weak AA battery
•
Correction: Unscrew the igniter cap and replace the
battery.
FLOW OF GAS SEEMS ABNORMAL
Check that gas cylinder is not empty.
1
.
Burner holes are dirty and clogged.
2
.
Gas regulator is not working.
3
.
SMELL OF GAS
Gas valve is open.
1
.
Gas hose is leaking(Check with soapy water)
2
.
Gas hose is bent or damaged or not positioned
3
.
properly.
Burnings of oils and fats left behind(oils & fats must be
cleared off from oven after cooking).
IMPORTANT
Should A flashback fire occur in or around the burner
•
tubes, follow the instruction below.Failure to comply
with these instructions could result in a fire or explo
-
sion that could cause serious bodily injury, death, or
property damage.
Shut off gas supply to the gas barbecue.
•
Turn the control knobs to off position.
•
Open the barbecue hood. Put out any flame with a fire
•
extinguisher.
Once the barbecue has cooled down,clean the burner
•
tubes and burners.
IF THE BARBECUE FAILS TO LIGHT
FLOW OF GAS SEEMS ABNORMAL
SMELL OF GAS
COOKER SMOKES
IMPORTANT
