![background image](http://html1.mh-extra.com/html/taylor-dunn/b5-440-gas/b5-440-gas_service-and-parts-manual_823366043.webp)
Engine
Page 43
MB-440-10
Bigfoot G-1500
AIR FILTER SERVICE
The air filter assembly consists of a foam pre-cleaner
over a paper filter. The pre-cleaner is oiled and must be
cleaned and re-oiled periodically. The pre-cleaner only
require replacement if it is damaged.
Do not operate the engine without the pre-cleaner.
Operating without the pre-cleaner will result in premature
failure of the engine.
1:
Remove the filter cover.
2:
Thoroughly clean the area around the filter
assembly.
3:
Remove the filter assembly.
4: Remove the pre-cleaner from the paper element.
5: Wash the pre-cleaner in water with detergent.
Rinse and allow to air dry.
6: Inspect the paper element and replace as
needed. DO NOT attempt to clean the paper
element.
7: Inspect the pre-clearer and replace if any damage
is found.
8:
Inspect the rubber filter seal and replaces as
needed.
9: Saturate the pre-cleaner with clean engine oil and
wring out excess oil.
10: Install the pre-cleaner around the paper element
and reinstall on the engine.
SPARK PLUG SERVICE
1: Allow the engine to cool.
2: Disconnect the battery negative cable.
3: Remove the cable from the spark plugs.
4: Thoroughly clean the area around each spark
plug.
5: Remove the spark plug and inspect the
electrodes for damage and condition and replace
as needed. See illustration below for typical
conditions of spark plugs.
•
Further engine service may be required if either
plug shows anything other than #1, #2, or #5.
6: Check the gap on each plug and adjust as
needed.
•
Gap: 0.030” (0.76mm).
7: Reinstall the plug and torque to 20 foot pounds
(27 Nm).
This section is one section of a complete service
manual. Before starting any procedure, read all
warnings and instructions that are located in the
Service Guidelines chapter.
WARNING
This section is one section of a complete service
manual. Before starting any procedure, read all
warnings and instructions that are located in the
Service Guidelines chapter.
WARNING
Summary of Contents for B5-440-GAS
