Be in charge
Super B
33
5.2.3. Battery balancing
During the batteries lifespan, the cells within the battery may be unbalanced due to high
discharge currents and short float charge periods. This may result in a loss of capacity and
overcharged cells.
The SB12V1200Wh-M automatically balances the cells if necessary. Balancing can take
place during charging and idle mode.
5.3. Power saving mode
When CANopen communication is switched off by the S2 configuration switch, battery goes
into power saving mode.
5.4. Battery History Recording
The complete battery history is stored inside the battery and can be accessed by your
reseller or by Super B.
6. Inspection, cleaning and maintenance
6.1. General information
!
Warning!
Never attempt to open or dismantle the battery! The inside of the battery does not
contain serviceable parts.
1. Disconnect the Li-Ion battery from all loads and charging devices before performing cleaning
and maintenance activities (see paragraph 4.8).
2. Place the enclosed protective caps over the terminals before cleaning and maintenance
activities to avoid the risk of contacting the terminals.
6.2. Inspection
1. Inspect for loose and/or damaged wiring and contacts, cracks, deformations, leakage or
damage of any other kind. If damage to the battery is found, it must be replaced. Do not
attempt to charge or use a damaged battery. Do not touch the liquid from a ruptured battery.
2. Regularly check the battery’s state of charge. Lithium Iron Phosphate batteries will slowly
self-discharge when not in use or whilst in storage.
3. Consider replacing the battery with a new one if you note either of the following conditions:
-
The battery run time drops below 80% of the original run time.
-
The battery charge time increases significantly.
6.3. Cleaning
If necessary, clean the Li-Ion battery with a soft, dry cloth. Never use liquids, solvents, or
abrasives to clean the Li-Ion battery.
Summary of Contents for Epsilon SB12V1200Wh-M
