2-1
122990-172
Uncrating Instructions
Installation/Uncrating Instructions
NOTE: The equipment in this container weighs approximately
1100 lbs (500 kg). Use a forklift to move washer.
NOTE: Uncrate on level floor as close to the installation site as
possible.
1.
Place crate in position to be opened from the top. Provide a
clear work area on all sides (see Figure 2-1).
2.
Carefully cut and remove bands from container.
3.
Discard bands before continuing.
1.
Lift off top wooden panels.
2.
Remove wooden side panels. Discard top and side panels.
3.
Remove foam sheets.
4.
Check tip indicator (located inside bottom service compart-
ment, see Figure 2-2). If unit has been tipped, notify the
STERIS Regional Office nearest you.
1.
Open bottom service compartment and remove the four lag
bolts holding washer to shipping base (see Figure 2-2).
2.
Using a forklift, lift the washer from base. If washer is too high
to be lifted by forklift, proceed to step 6.
Figure 2-2. Remove Lag Bolts
Figure 2-1. Position Crate
Top
Bands
Container
Nails
Lag
Bolts
Tip Indicator
Wood Base
Lag Bolts
Remove Base and Move
Washer/Disinfector
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
Remove Crate
and Packing
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
WARNING - LACERATION HAZ-
ARD: When removing bolts, wear
gloves to protect your hands.
Open the Crate
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
12345678901234567890123456789012123456789012345678901234567
WARNING - PERSONAL INJURY
AND/OR EQUIPMENT DAMAGE
HAZARD: When moving washer/
disinfector, use a forklift. Do not
use doors or door handles for
lifting.
WARNING - LACERATION/EYE
INJURY HAZARD: When remov-
ing bands, wear eye protection
and always use a tool specifically
designed to cut the bands. The
bands used to secure this con-
tainer can cause personal injury
when cut and tension is released.
UNCRATING INSTRUCTIONS
2
