SECTION THREE – Heater Operation
8. Turn the Gas Control Knob counterclockwise to the
ON position. On newer models, throw the ON-OFF
toggle to ON.
9. Replace and bolt together both halves of the Jacket
Cover. The Jacket Cover must be in place when
operating the heater.
10. Set 3-way valves on inlet and outlet to pool or spa,
as appropriate.
11. Turn on all electric power to the heater.
12. Press either the POOL ON or SPAON touch pads
on the Membrane Pad.
13. Press the TEMP
▲
or TEMP
▼
touch pads to set the
desired temperature.
14. The Blower will come on immediately and, after
about 20 seconds, the Burner will fire. If the Burner
does not fire, push the OFF switch, wait five min-
utes, and push either the POOL ON or SPAON
switch. Repeat if needed.
15. The Burner should fire until the pre-set pool/spa
water temperature reaches the temperature set on
the thermostat. The Blower will continue to run for
about 45 seconds after the burner shuts off.
16. If the heater will not operate, follow the instructions
in “Turning Off Gas to the Heater” below.
Turning Off Gas to the Heater
If the heater will not operate, use the following proce-
dure to turn off the gas supply to the heater:
1. Press the OFF button on the Membrane Pad.
2. Turn off all electric power to the heater.
3. Remove Jacket Cover.
CCCCAAAAUUUUTTTTIIIIOOOONNNN:::: Heater parts may be hot after operation.
4. Turn the Gas Control Knob clockwise to the red
line, press slightly, then turn the knob to the OFF
position (or throw ON-OFF toggle to OFF).
5. Replace the Jacket Cover.
3-2
You are
here
You are here
Gas control is shown ON.
Turn Clockwise and press
down to turn gas off.
ON
OFF
OFF
Gas is now OFF
2671 1096
Indexing Point
Operating Instructions
Figure 3-3: Combination Gas Valve,
Turning Gas OFF
Indexing Point
Gas control is shown OFF.
Turn Counter-clockwise
and release to turn gas on.
You are
here
You are here
OFF
ON
ON
Gas is now ON.
2672 1096
Figure 3-2: Combination Gas Valve,
Turning Gas ON
SSSSaaaaffffeeeettttyyyy PPPPrrrreeeeccccaaaauuuuttttiiiioooonnnnssss::::
See Page 3-1.
Note:
Newer models are equipped
with an ON-OFF toggle switch
which replaces the Gas
Control Knob.
Figure 3-1:
