Skyjack SJ6826 RT, Operating Manual

Page: 17 / 92

Rough Terrain Scissors
December 2007 Page 17
Section 2 - Familiarization Visual & Maintenance Inspection
It is the responsibility of the operator to read, completely understand and follow all instructions and warnings
contained in this operating manual and on the aerial platform.
FAMILIARIZA
TION
FAMILIARIZA
TION
2.3-5 Engine Compartment
-
Ensure compartment latch is secure and
in proper working order.
• Main Power Disconnect Switch
-
Turn main power disconnect switch to
“ ” off position.
-
Ensure all cables are secure and switch
is in proper working condition.
• Base Control Switches
-
Ensure there are no signs of visible
damage and all switches are in their
neutral positions.
• Load/Tilt Sensor
-
Ensure load/tilt sensor is properly secure
and there is no visible damage.
• Battery
Proper battery condition is essential to
good performance and operational safety.
Improper fluid levels or damaged cables and
connections can result in component damage
and hazardous conditions.
WARNING
Explosion hazard. Keep flames
and sparks away. Do not smoke
near batteries.
WARNING
Battery acid is extremely corrosive -
Wear proper eye and facial protection as
well as appropriate protective clothing.
If contact occurs, immediately flush with
cold water and seek medical attention.
1. Check battery case for damage.
2. Clean battery terminals and cable ends
thoroughly with a terminal cleaning tool
or wire brush.
3. Ensure all battery connections are tight.
4. If applicable, check battery fluid level. If
plates are not covered by at least 13 mm
of solution, add distilled or demineralized
water.
5. Replace battery if damaged or incapable
of holding a lasting charge.
WARNING
Use original or manufacturer-approved
parts and components for the MEWP.
• Hydraulic Pump
-
Ensure there are no loose or missing
parts and there is no visible damage.
Main Power
Disconnect Switch
Battery
Base Control
Console
Engine Air Filter
Hydraulic Pump
Radiator
Muffler and Exhaust
Engine
Fuel Shut-off Valve
Load/Tilt
Sensor