Site configuration
Site survey:
The Ultra 50 can be installed onto a newly prepared concrete
pad, or onto an existing concrete surface, with service wiring
supplied through conduit via the foundation or above ground.
If a foundation to supply power from underground is to be
prepared, follow the underground power instruction for
installation.
If the charger is to be installed onto an existing concrete surface,
follow the above ground power instruction for installation.
The Ultra 50 is best installed following the recommended site
configuration requirements.
Ground fixing:
The Ultra 50 is to be fixed to the ground through the baseplate
fixing holes with 4 x M16 or 5/8-11 inch fasteners (not supplied).
The fasteners should fix the Ultra 50 securely to the foundation
through the baseplate and protrude 30-40mm/1.2-1.6 inch
maximum from the foundation surface, in accordance with the
dimensions and fixing points shown in: Figure 5: Fixing guide.
See Figure 1: Dimensions walls or obstacles, for installation
against or near walls or other obstacles.
Foundation requirements:
The foundation must be flat, even, and the appropriate density
for the weight of the Ultra 50.
Check the flatness and level of the foundation and level of the
Ultra 50 baseplate prior to fixing.
Communications:
4G network capability or Ethernet.
The Ultra 50 is fitted with a Harting external IP65 rated Ethernet
port. This port can be accessed temporarily during installation.
If a more permanent, sealed connection is required, use Harting
external Ethernet connector, 9153000401. See page 23 for
Ethernet port access.
Site restriction:
Installation shall not be done in a commercial garage (repair
facility) or closer than 6 meters/20ft of an outdoor motor fuel
dispensing device.
CAUTION
A qualified engineer must survey the installation site to
determine the correct ground preparation for the size and
weight of the Ultra 50, in accordance with all local applicable
codes and regulations.
VersiCharge Ultra 50™ |
Installation Manual
8
Summary of Contents for VersiCharge Ultra 50
Page 2: ...2 ...
