2
SeaStar Hydraulic Steering
BEFORE OPERATING YOUR
BOAT FOR THE FIRST TIME
Ensure that the following check list is carried out.
1.
Perform system pressure test by turning helm all the way hard over
and then forcing the helm another 1/4 – 1/2 turn. This must be
completed in both directions. This will pressurize the system. Any
weakness (faulty hose, leaks, etc.) will be seen at this time
2.
Confirm that there is NO interference between the steering cylinder(s),
or the Kicker Cable Tiebar with the transom, splashwell or any
other object by performing the following steps;
• With engine fully tilted, turn steering wheel from hard over to hard
over, confirming that there is no interference. If using a hydraulic
jack plate this also must be performed at the top and bottom
position of the jack plate. (If interference is present, it MUST be
eliminated with trim limiting switches and/or jack plate lift
restrictors. Contact jack plate manufacturer for advice if required).
• Confirm that the steering cylinder can be fully stroked in both
directions, as well as full tilt/trim without stretching and/or
kinking the hydraulic hoses, or, Kicker Cable Tiebar.
• Confirm that the hydraulic hoses and/or Kicker Cable Tiebar
are not subject to chafing or rubbing.
NOTE:
Stretched or kinked hose/cables will fail over a period
of time.
Prior to 'every use', please refer to page 12 for important
safety checks.
Failure to comply with the above and ANY other warning, notice or
caution may lead to loss of steering control. Loss of steering control
may result in unpredictable boat behaviour leading to ejection from
boat, property damage and/or personal injury or death.
To maximize component life and performance—when the boat is
being transported on a trailer, ensure that one of the following
steps is performed.
• Turn steering wheel hard over so that the cable exiting the 'kicker
motor' is fully EXTENDED" (see figure 2, page 3 for details).
• Center the engine and use steering-stops to prevent the engine
from falling over.
• Disconnect the Kicker Cable Tiebar from the main steering
cylinder (see page 11 for details).
WARNING
WARNING
NOTICE
