Section 03
TROUBLESHOOTING
Subsection 01
(TROUBLESHOOTING CHART)
SMR2000-006_03_01A.FM
03-01-1
TROUBLESHOOTING CHART
0
The following is provided to help in diagnosing the probable source of troubles. It is a guideline and should
not be assumed to have all causes for all problems.
NOTE:
On GTX RFI and GSX RFI models, always check for active fault codes recorded in the ECU first.
If a fault code is detected, service the fault code first and recheck operating conditions.
Refer to FUEL INJECTION for the procedure and the fault code table.
ENGINE WILL NOT START
OTHER OBSERVATION
POSSIBLE CAUSE
REMEDY
Engine does not turn over
• DESS operation non functional
• If 2 short beeps are not heard when
installing safety lanyard, refer to
DIGITALLY ENCODED SECURITY
SYSTEM
• Safety lanyard switch or harness
damaged
• Replace
• Burnt 5 A fuse on MPEM
• Check wiring then replace fuse
• 5 A fuse keeps on burning
• Check wiring, solenoid and MPEM
• Discharged battery
• Check/recharge
• Battery connections
• Check/clean/tighten
• Water/fuel hydrolock
• Check, refer to subsection 02-04
• Starter
• Check, refer to subsection 08-04
• Seized engine
• Check/repair as needed
• Seized jet pump
• Check, refer to subsection 09-02
• Faulty sensor or ECU (RFI)
• Check faulty codes in ECU memory,
refer to subsection 06-05
Engine turns slowly
• Discharged/weak battery
• Check/charge/replace
• Restriction in jet pump
• Check/clean pump
• Seizure in jet pump
• Inspect, refer to subsection 09-02
• Partial engine hydrolock
• Check, refer to subsection 02-04
• Partial engine seizure
• Check compression, refer to
subsection 04-05
• Worn starter
• Check, refer to subsection 08-04
www.SeaDooManuals.net
Summary of Contents for 2001 GS
