Page 26
7022-122
January 19, 2011
R
Castile Pellet Insert
C. General Operating Information
1. Thermostat Calls For Heat
The appliance is like most modern furnaces; when the thermostat
calls for heat, your appliance will automatically light and deliver
heat.
When the room is up to temperature and the thermostat is
satisfi ed, the red call light will shut off and the appliance will shut
down. The red call light is located behind the right access panel.
Figure 26.1
2. Heat Output Controls
This appliance is equipped with a heat output control switch
that has three settings or burn rates; low, medium and high.
Figure 26.1.
The appliance will turn on and off as the thermostat demands.
When the thermostat calls for heat, the appliance will always
start up on High. After burning approximately 4 minutes, the
appliance will then burn at the rate at which it was originally
set. If the appliance is set at one of the lower settings, it will
run quieter but takes longer to heat up an area than if it were
set at a higher burn rate.
Regardless of the burn rate, when the area is warm enough to
satisfy the thermostat, the appliance will shut off.
WARNING
Fire Hazard.
Keep combustible materials, gasoline
and other fl ammable vapors and liquids
clear of appliance.
• Do NOT store fl ammable materials in the appliance’s
vicinity.
• DO NOT USE GASOLINE, LANTERN FUEL, KEROSENE,
CHARCOAL LIGHTER FLUID OR SIMILAR LIQUIDS TO
START OR “FRESHEN UP” A FIRE IN THIS HEATER.
• DO NOT BURN GARBAGE OR FLAMMABLE FLUIDS
SUCH AS GASOLINE, NAPHTHA OR ENGINE OIL.
• DO NOT USE CHEMICALS OR FLUIDS TO START THE
FIRE.
• Keep all such liquids well away from the heater while it is in
use.
• Combustible materials may ignite.
High
Med
Low
Reset
Button
D. Before Your First Fire
1. First, make sure your appliance has been properly installed
and that all safety requirements have been met. Pay
particular attention to the fire protection, venting and
thermostat installation instructions.
2. Double check that the ash drawer and fi rebox are empty!
3. Close the front door.
CAUTION
Tip of thermocouple must be in contact with the
inside end of the thermocouple cover.
Missed ignitions can occur.
WARNING! RISK OF FIRE!
Keep combustible materials,
gasoline and other
fl ammable vapors and liquids clear of
appliance.
• Do
NOT
store
fl ammable materials in the appliance’s vicin-
ity.
• Do
NOT
use gasoline, lantern fuel, kerosene, charcoal lighter
fl uid or similar liquids to start or “freshen up” a fi
re in this
heater.
Keep all such liquids well away from the heater while it is in use
as combustible materials may ignite.
E. Clear Space
WARNING! RISK OF FIRE!
Do NOT place combustible
objects in front or to the sides of the appliance. High tempera-
tures may ignite clothing, furniture or draperies.
NOTICE:
Clearances may only be reduced by means approved
by the regulatory authority having jurisdiction.
Mantel:
Avoid placing candles and other heat-sensitive
objects on mantel or hearth. Heat may damage these objects.
