Location of Parts
Removal of Left / Right Side Cover
•
Access to battery is by removing LH cover.
•
Insert ignition key & turn it clock wise.
•
Pullout the cover from fuel tank knob.
• Slide the cover towards left direction.
•
Direction of removal is important to avoid
breakage of cover locking lug.
Tool Kit Location
•
It is located below Rr. seat. For
removing seat please refer procedure
given on page number 9.
•
2 rubber straps are provided to hold the
tool kit.
Battery (12V - 9Ah)
• Battery is located inside LH side cover.
• Check electrolyte level in each cell &
ensure that it is between upper & lower
level lines.
• Remove battery filler caps and fill with
distilled water until electrolyte level in each
cell reaches upper level line.
• Add only distilled water to battery. Tap
water is not a substitute for distilled water
and will shorten the life of battery.
• Environment care is to be taken to dispose
off used battery. It is always recommended
to handover same to Authorised Battery /
Bajaj Dealer for proper disposal of same.
• Warranty on battery is 18 months from the
date of purchase of vehicle.
Location of Parts
A) Dipper switch :
When headlight is ON, High
or Low beam can be selected with the dipper
switch. : High Beam : Low beam
B) Turn signal switch :
When the turn signal
switch is turned to Left ( ) or Right ( ),
the corresponding turn signals flash on and
off. To stop flashing, push the switch in
opposite direction of indicator.
Auto Cancellation of Indicators
•
After having turned to LH or RH directions,
the indicators would switch off itself when
the handle bar is straightened.
•
If one forgets to take a turn, but has
selected the turn signal it will be switched
off automatically after approx. 1 min.
C) Horn button :
( ) Press for sounding horn.
Battery
Left Handle Bar Switches
C
B
A
D
G
E
F
Right Handle Bar Switches
D) Pass Switch :
Press the switch to flash the
head light. It should be used to give signals
to on coming vehicles while overtaking.
: All lamps 'OFF'.
: Tail, Meter, Pilot lamp/s ‘ON’.
: Head, Pilot, Tail, Meter lamps ‘ON’.
E. Head Light Switch :
It has 3 positions.
F. Starter Button :
Push start button to start the
engine with transmission in neutral position.
In geared condition pressing clutch lever
would be required.
G. Engine Kill Switch :
During emergency move
engine kill switch to the OFF ( ).
Caution :
While starting ensure that engine
Kill switch is in on ( ) position. Engine will not
Start if the kill switch in OFF ( ) position.
7
8
