Polaris A09BA50FA, User Manual

Page: 27 / 256

MAINTENANCE
2.17
CHOKE (ENRICHER)
ADJUSTMENT
Boot
If the choke knob does not stay out when pulled,
adjust the choke tension by tightening the tensioner
located under the rubber boot between the choke
knob and nut.
Firmly grasp the rubber boot and
tighten until the choke slides freely but stays out when
pulled.
Verify free play of 1/16--3/16” (1.6--4.76 mm) and
smooth operation of choke cable.
If smooth choke operation is not obtainable, inspect
choke cable for kinks or sharp bends in routing.
FUEL SYSTEM
WARNING
Gasoline is extremely flammable and explosive
under certain conditions.
G
Always stop the engine and refuel
outdoors or in a well ventilated area.
G
Do not smoke or allow open flames
or sparks in or near the area where
refueling is performed or where
gasoline is stored.
G
Do not overfill the tank. Do not fill the
tank neck.
G If you get gasoline in your eyes or if
you swallow gasoline, seek medical
attention immediately.
G
If you spill gasoline on your skin or
clothing, immediately wash it off with
soap and water and change clothing.
G Never start the engine or let it run in
an enclosed area. Engine exhaust
fumes are poisonous and can result
loss of consciousness or death in a
short time.
G Never drain the float bowl when the
engine is hot.
Severe burns may
result.
FUEL LINES
Pulse Line
Fuel Lines
Fuel Pump
Fuel Filter
Ill.1
1. Check fuel lines for signs of wear, deterioration,
damage or leakage. Replace if necessary.
2. Be sure fuel lines are routed properly and secured
with cable ties. CAUTION: Make sure lines are
not kinked or pinched.
3. Replace all fuel lines every two years.