3
Nexel Chest Freezer
• Do not fill the freezer full of products. You should
leave space between items and the inner surface of
the cabinet, so as to keep good ventilation of cold air
and freeze evenly. Do not put in any bottled or canned
beverage with freezing point above the temperature in
the cabinet when it is below zero.
• For foods that should be moisture-free or lose water
easily, wrap them up with hermetical food bags or
fresh films before putting in the cabinet for the sake of
avoiding smell-mixing and reducing frosting.
• Storage of volatile and combustible gases, liquids
such as strong alkalies, strong acids, gasoline, etc. is
forbidden.
• Never put hot food directly in the freezer. Food should
be cold or frozen before placing it inside.
• The cabinet is intended exclusively for the storage and/
or display of packaged foods only.
Food Storage
• The freezer should be cleaned regularly. When
cleaning, turn off the power, take out the foods in the
cabinet, clean the inside using water or a little neutral
detergent.
• Do not use boiling water, acid, chemical diluents, oil,
or dirt-removing powder.
• Wipe dry after cleaning.
• Use light soap water when cleaning the door seal,
apply a little of talcum powder on it after natural drying
to extend its service life.
• Use soft cloth with water or a little detergent to clean
the out surface. Note, keeping the power supply and
lower part of connect wires away from water to avoid
electricity leakage.
• Except common breakdowns, those who are not
certified service technicians should not disassemble
or repair the freezer on their own. Unauthorized repair
of electrical part such as compressor, temperature
controller is forbidden and will void warranty.
Maintenance
• The freezer should be cleaned regularly. When
cleaning, turn off the power, take out the foods in the
cabinet, clean the inside using water or a little neutral
detergent.
• Do not use boiling water, acid, chemical diluents, oil,
or dirt-removing powder.
• Wipe dry after cleaning.
• Use light soap water when cleaning the door seal,
apply a little of talcum powder on it after natural drying
to extend its service life.
• Use soft cloth with water or a little detergent to clean
the out surface. Note, keeping the power supply and
lower part of connect wires away from water to avoid
electricity leakage.
• Except common breakdowns, those who are not
certified service technicians should not disassemble
or repair the freezer on their own. Unauthorized repair
of electrical part such as compressor, temperature
controller is forbidden and will void warranty.
Defrosting
Breakdown
Case
Removal method
The indicator is not on.
The compressor doses not
start.
The plug isn’t connected to the socket properly.
Connect plug to socket.
No power
Check power connection.
No power
The indicator is on ,but the
com- pressor doesn’t work and
buzzes only
The power voltage is < 98V.
Install a power-regulator more than 1000W
The compressor stops a
minute after start, and restarts
after a few minutes, and so
repeatedly.
The power voltage is > 132V.
The compressor works
normally, but the temperature
in the cabinet decreases too
slowly.
The door is opened too frequently.
Reduce the amount of times the door is open.
There is too much food in the cabinet and/or placed
improperly.
Decrease the amount of food in the cabinet and/or keep enough
space between foods for proper ventilation of cold air.
The frost film is too thick.
Take out foods and defrost.
The surface of the condenser is too dirty.
Stop and clean the condenser.
The door seals badly.
Adjust the door seal.
The noise is too loud
The freezer is on an uneven surface or is unstable.
Place on an even surface.
Hardware of the freezer is loose.
Check and tighten all hardware.
There’s contact between pipes.
Carefully separate pipes.
The following are not faults:
• When the freezer is working or after stopping for a while, the refrigerant in the pipes is cycling and will give off a
“running water
” sound. This is normal.
• The surface temperature of the compressor can be up to
70°~80°F
when it is working.
• The back side of step freezer gives off heat.
• In rainy season, the outer surface of the cabinet may have dew, which makes no defects on normal use. Just dry it
with a piece of cloth.
Troubleshooting