![background image](http://html1.mh-extra.com/html/multiquip/da7000ssa2/da7000ssa2_operation-and-parts-manual_1855176062.webp)
PAGE 62 — DA7000SSA2/SSA2GH GENERATOR• OPERATION AND PARTS MANUAL — REV. #0 (03/26/15)
NAMEPLATE AND DECALS ASSY.
16
FRONT VIEW
SIDE VIEW
2
S-1409
DO NOT
OPERATE WITH
DOORS OPEN
CAUTION
WARNING
HOT COOLANT can cause
severe burns.
DCL183
DO NOT
remove cap if
radiator is hot.
COOLING
WATER
S-3061
DECAL
KIT
ON
OFF
FUEL COCK
COOLIN
G
W
ATE
R
S-3
061
S-1408
USE #2 DIESEL
FUEL ONLY
18
19
17
H
L
CAUTION
DCL194
RESERVE
TANK
WATER
COOLANT
LEVEL
1. Radiator water level.
2. Reserve tank water level.
(Important) Not more than
a 50/50 Anti-Freeze/Water
mixture is recommended.
3. Engine oil level.
CHECK DAILY
OFF
ON
FUEL COCK
23
CAUTION
OIL LEVEL
DIPSTICK
H
L
Before starting the engine, check that the oil
level is within the indicated operating range.
If the level is above the
or below
the
, it is important to correct before
operating to avoid damage to the engine.
H
L
mark
mark
DANGER
Cigarettes, flames or sparks could cause battery to explode. Always
shield eyes and face from battery. Do not charge or use booster cables
or adjust post connections without proper instruction and training.
EXPLOSIVE GASES
KEEP VENT CAPS TIGHT AND LEVEL
POISON
CAUSES SEVERE BURNS
Contains sulfuric acid. Avoid contact with skin, eyes or clothing. In
event of accident flush with water and call a physician immediately.
KEEP OUT OF REACH OF CHILDREN
S-4985
DANGER
Do not touch output
terminals or
internal wiring while
unit is operating.
Turn off power b
efore servicing.
Only qualified pe
rsonnel should
install, use or se
rvice this
equipment.
ELECTRICAL
SHOCK
HAZARD
AC CIRCUI
T
BREAKE
R
OFF
22A
120
V
20A
120V
OFF
ON
GA-2.9 R
2900
DANGER
Using a generator indoors
CAN KILL
YOU IN MINUTES
Generator exhaust contains carbon monoxide. This is
a posion you cannot see or smell
NEVER
use inside a home
or garage, even if doors
and windows are open
AC CIRCUI
T
BREAKER
OFF
22A
120
V
20A
120V
OFF
ON
GA-2.9 R
2900
AC CIRCUI
T
BREAKE
R
OFF
22A
120
V
20A
120V
OFF
ON
GA-2.9 R
2900
Only use OUTSIDE and
far away from windows,
doors, and vents.
Avoid other generator hazards.
.
READ MANUAL BEFORE USE
GROUND RO D
FOR EART H
GROUND
GEN
ERA
TOR
GRO
UND
LU
G
CONNECT TO
BUILDIN G
GROUND
(OPTION)
8 FT . MINIMU M
REFERENCE
NEC 250-52(C)
DANGER
THE POSSIBILITY EXISTS OF
IF
GENERATOR/WELDER IS NOT PROPERLY GROUNDED.
ALWAYS CONNECT EARTH GROUND (GROUND
ROD) TO GENERATOR G.F.C.I. GROUND TERMINAL.
ELECTROCUTION
G. F. C. I
GROUND
STUD
GROUND
CABL E
#8 MINIMU M
FOR FURTHER GROUNDING
INSTRUCTIONS, READ MANUAL
D93110000
AC POWER OUTPUT
A55200000A
30A
50A
120V/240V
30A
20A
120V
30
38
9
2
33
32
15
35
To avoid injury,
you MUST read
and understand
operator’s manual
before using this
machine.
Ask for training
as needed.
This machine to
be operated by
qualified
personnel only.
P/N 35137
WARNING
4
COOLANT DRAIN
S-1404
FUEL DRAIN
S-3060
CAUTION
CLEAN OR
REPLACE
PAPER ELEMENT
EVERY 100 HOURS
S-1406
OIL DRAIN
S-1403
GROUND
for
G.F.C.I
S-3821
10
GROUND
S-1123
CAUTION:
DO NOT
OPERATE WITH
DOORS OPEN
S-1409
USE #2 DIESEL
USE ULTRA LOW SULFUR
FUEL ONLY
S-1408
14
26
29
31
A555000103
1. Check the oil level.
2. Check the water level.
3. Check the fuel level.
4. T urn the Idle Control switch to “ON.”
5. Insert the key into the Starter Switch.
6. T urn the key to “RUN”. The Charge
Warning lamp and the Oil Pressure Warning lamp
should be lit.
7. Turn the key to “HEAT.” When the preheat lamp
lights turn the key to “START” to start the engine.
AVOID HIGH SPEEDS IMMEDIATELY AFTER
STARTING.
8. When the engine starts, the Oil Pressure
Alarm lamp should go out.
9.
10.
Let the engine idle for more than 5 minutes
with the Idle Control switch in “ON” position.
Check the engine for abnormal vibrations noise
and oil leakage.
11. T urn the Idle Control switch to either “ON” or
“OFF” for full engine operation.
12. After generating let the engine run for 5 minutes
with the Idle Control switch in the “ON” position.
NEVER STOP THE ENGINE SUDDENLY EXCEPT
IN AN EMERGENCY.
13. Stop the engine by turning the key in the
Starter Switch to “STOP” and remove the key.
OPERATING PROCEDURE
MULTIQUIP WhisperWatt
AC Generator
5
37
24
Before connecting this generator to any building’s
electrical system, a licensed electrician must install
an isolation [transfer] switch.
Serious injury or death may result without this
transfer switch.
WARNING!
3
27
12
11
8
7
cooled.
CAUTION
can burn skin.
DCL181
touch until the
machine has sufficiently
HOT PARTS
DO NOT
22
DANGEROUS
GAS
S-4984
WARNING
Only operate machine in well ventilated
areas.
DO NOT
inhale exhaust gases.
Only qualified personnel should
install, use or service this
equipment.
WARNING
MOVING PARTS can cause
severe injury.
DCL182
DO NOT
operate with
doors open.
Stop engine before
servicing.
6
WARNING
DIESEL FUEL can cause
B90450000
fire or explosion.
Stop engine before fueling.
Keep cigarettes, sparks
and flame away.
.
.
FUSE PULLY
USE SPECIFIED FUSE ONL
Y.
5A
F6
F5
F4
F3
F2
F1
15A
5A
5A
5A
30A
SP
AR
E
15A
30A
S-2090
S-2090
20
A9210 0260
G.F.C.I. PROTECTED
ALL RECEPTECALES
S-3031
CIRCUIT BREAKER
21
34
13
36
1
A9210 0350
for
120V
20A
for
120V
30A
for
120V/240V
30A
25
WARNING
Operation of
this equipment
may create
sparks that can start
fires around
dry
vegetation.
A spark arrestor
may be required.
The operator
should cont
act local fire
agencies for laws or
regulation relat
ing
to fire prevention requirements.
M9042 0000
27
28
WARNING
MOVING PARTS can cause
severe injury.
DCL182
DO NOT
operate with
doors open.
Stop engine before
servicing.
Summary of Contents for DA7000SSA2
