MULTIQUIP DA7000SSA2, Operation And Parts Manual

Page: 35 / 160

DA7000SSA2/SSA2GH GENERATOR• OPERATION AND PARTS MANUAL — REV. #0 (03/26/15) — PAGE 35
Cleaning the Fuel Filter
Every 100 hours:
Clean fuel filter every 100 hours of
operation or once a month to remove dust or water.
1. Place fuel cock lever (Figure 36) in the close position.
2. Disconnect fuel lines from fuel filter.
Figure 36. Fuel Cock Lever (OFF)
Replacing Fuel Filter Element
First 50 And Then Every 200 hours:
Replace fuel filter
element.
1. Remove the top cap (Figure 37) from the fuel filter and
rinse cap and filter bowl with diesel fuel.
2. Remove element, and rise with diesel fuel.
3. Reinstall fuel filter and connect fuel lines.
Figure 37. Fuel Filter Disassembly
4. Inspect all fuel lines every 50 hours.
MAINTENANCE
Radiator
Check Daily: Always check the level of the coolant in the
radiator before starting the engine. Remove the radiator
cap and verify that the coolant reaches top of radiator coils.
1.
DO NOT
remove the radiator cap while the coolant is
hot. The possibility exists of severe burns or scalding
from the coolant gushing out. Let the coolant cool
before removing radiator cap.
2. Check coolant in the reserve tank daily (Figure 38).
Make sure the level is between the FULL (
H
) and LOW
( L ) markings. Fill reserve tank with a mixture of 50/50
antifreeze/water.
Figure 38. Radiator/Reserve Tank
Flushing Out Radiator and Replacing Coolant
1. Remove radiator coolant plug (Figure 39) located at
the bottom of the generator enclosure and drain
radiator coolant. Open the radiator cap while draining.
Remove the overflow tank and drain.
Figure 39. Coolant Drain Plug
OIL DRAIN
COOLANT DRAIN
COOLANT DRAIN
PLUG