Lance 1130, Owner'S Manual

Page: 79 / 132

79
PROPANE SYSTEM
Please observe the warnings and cautions contained
in this section as well as the manufacturers supplied
information with each gas appliance.
Propane is stored in a high-pressure tank in liquid
form and is delivered to the appliances in a gaseous
form. The propane container(s) must not be placed
or stored inside a vehicle. The container(s) are
equipped with safety devices that relieve excess
pressure by discharging propane to the atmosphere.
BTU’S
One gallon of propane produces approximately
91,502 BTU’s. Using the BTU rating of each gas
appliance in your RV, your can determine about how
long your supply will last according to your usage.
Dual 5 gallon propane bottles hold approximately
862,026 BTU’s. Dual 7 gallon propane bottles hold
approximately 1,294,840 BTU’s.
Listed below is the rating of the appliances on your
Lance Trailer:
Water Heater 8800 BTU
Furnace 20000 BTU
Refrigerator 1500 BTU
Cooktop 9000 BTU large burner
6500 BTU small burners
5600 BTU oven
SAFETY PRECAUTIONS
Propane is of course highly flammable and also
heavier than air. It’s treated to have a garlic like
odor to detecting a leak. If a leak should occur, the
propane can collect in pockets along the floor and
thereby dissipate the air. If unnoticed, this could result
in suffocation or an explosion.
DANGER
IF YOU SMELL PROPANE
1. Extinguish any open flames, pilot lights
and all smoking materials.
Do not touch electrical switches. Shut off
the propane supply at the tank valve(s) or
propane supply connection. Open door
and other ventilating openings. Leave the
area until odor clears.
Have the propane system checked and
leakage source corrected before using
again.
2. Inspect the entire propane system for
leaks or damaged parts before each trip.
3. Never check for leaks with an open flame.
Use an approved leak detection solution
or a non-ammoniated, non-chlorinated
soap solution only. If the leak cannot be
located, have the system checked by
qualified personnel.
4. Always be careful when drilling holes or
fastening objects to the trailer. A nail or
screw could puncture the propane supply
lines.
5. Do not restrict access to propane tanks.
In an emergency, the tank service valve
must be easily accessible. Do not store
items or block ventilation openings in the
propane compartment.
6. Do not use any propane tanks other than
those furnished with your trailer.
Turn off main propane valve and
individually turn off all propane
appliances or electrically disconnect
automatic ignition appliances before
entering propane bulk plant or motor fuel
service station. When not individually
turned off, automatic ignition appliances
may continue to spark. Do not fill propane
containers to more than 80 % capacity.
Overfilling can result in uncontrolled
propane flow that can cause fire and
explosion. A properly filled container
holds about 80 % of its volume as liquid.
7. Propane regulators must always be
installed with the diaphragm vent facing
downward within 45° of vertical to
minimize vent blockage that could result
in excessive propane pressure causing
fire or explosion.
8. Do not use a wrench or pliers to close the
service valve. This valve is designed to
be closed leak-tight by hand. If a tool is
required to stop a leak, the valve probably
needs repair or replacement.
9. When attaching the hose connector to the
valve, don’t force, jam or cross-thread the
fitting. Always check fitting for leaks after
tightening.
10. Be sure the tanks are securely fastened
whenever they are mounted on the trailer.
11. Go to a Lance Trailer Dealer for any
propane system repairs.
12. Always think safety.