56 General Maintenance
7.
Before extending the telescopic cylinder, be sure to place the same piece of wood that was used
during the packer removal procedure to help support the cylinder during extension.
8.
Start the engine and engage the hydraulic system (P
UMP
switch set to “ON”).
Wait for the air pressure to reach 70 psi before engaging the hydraulic system.
9.
On the packer control station, press the green P
ACK
button (see Figure 3
23) to fully extend the
packer cylinder.
Be careful when the cylinder reaches the packer; its front-end must go inside the packer through
the tunnel hole (see Figure 3
37) up to the tip of the packer tunnel.
10.
When the cylinder eye-end is aligned with the side holes of the tunnel tip, press the red
E
MERGENCY
S
TOP
button (see Figure 3
25).
11.
Proceed with the tagout/lockout procedure. Refer to “Locking Out and Tagging Out the
12.
Secure the cylinder front-end with the pin (see Figure 3
27).
Figure 3
-
37 Packer tunnel hole (packer turned upside down)
13.
Put the bolt back in to secure the pin cover to the tunnel tip.
14.
Reinstall the tunnel cap (see Figure 3
26) using the same bolts.
15.
Be sure to remove the piece of wood used to support the telescopic cylinder during extension.
Caution
Make sure the ball valve on the suction line is fully open before starting the vehicle.
Warning!
Slowly extend the cylinder to avoid impact that could cause damage to the equipment.
Summary of Contents for AUTOMIZER FULL EJECT
