-
-
7. PERIODIC MAINTENANCE AND SERVICE
Interval
Item
Each
time used
First used
or 20Hrs
Each three
months or
100Hrs
Each six
months or
500Hrs
Each
year or
1000Hrs
Check each two year, replace if the pipe is aged and transmutative.
First time
Replace
(2)
(2)
-
-
9. Load
Do not start 2 or more machines simultaneously. Start them one by
one.
Do not use floodlight together with other machines.
Open the breaker, observe the voltmeter on the control panel, the voltmeter
should point to 230V
5% (50Hz) for single-phase generating set; about 400V
(50Hz) for three-phase generating set, then the loading can be carried out.
Connect the equipment to the generating set in order. For the matter of the
motor load, firstly the heave-duty motor should be connected, and then the light-
duty motors. If the operation is false, the generating set will lag or stop suddenly.
It is necessary to unload the generating set immediately and turn off the main
switch and do checks.
Electrical equipment (including electrical lines and plugs connection) could not
be defective. By the effect of mechanical stress, make sure to use the rubber
sheathed flexible cable or analog (accord with IEC245-4).
Limit length of electric line when using the extension line or distributed network
is: less than 60m for cables of 1.5mm2, and less than 100m for cables of 2.5mm2.
CAUTION
CAUTION
Periodic maintenance and service are very important for keeping the engine in
good condition durable.
Stop the generator before performing any service. If the generator must be run,
make sure the area is well ventilated. The exhaust contains poisonous carbon
monoxide gas.
1. Periodic maintenance table
Oil
Battery
electrolyte
Air filter
Fuel filter cup
Spark plug
Valve clearance
Cylinder cover
Fuel tank
Fuel pipe
Check
Replace
Check
Refill
Check
Clean
Clean
Clean
regulate
Clean
regulate
Clean
Clean
Check
First: it is the first check time. After that, check according to the normal period.
The checking time is slightly different between the different engines, please refer
to the engine manual.
Note
1) It is necessary to shorten the maintenance interval when used in dirty areas..
2) This item maintained by Kipor agent.
3) Don't pour waste oil into the sewer or the river to prevent environment pollution.
The exhaust oil from generator must be stored in container. To deal with bad
matter, such as fuel, oil cooling water, solvent, filter and battery, according to the
local law.
Stop the engine before maintaining.
CAUTION