4 MAINTENANCE
GB-18
4.5
DIESEL AIR FILTER ________________________________________________________
Check the service indicator daily. If red band appears in the
window
(C)
replace the element.
Do not remove the element for inspection or cleaning.
Unnecessary removal of the filter increases the risk of
injecting dust and other impurities into the engine.
When service is required, first clean the outside of the filter
housing; then remove the old element as gently as possible
and discard.
1. Carefully clean the inside of the filter housing without
allowing dust into the air intake.
2. Inspect the new element. Do not use a damaged
element and never use an incorrect element.
3. Assemble the new element and make sure it seats
properly. Reset the indicator by depressing button
(D)
.
4. Reassemble cap making sure it seals completely
around the filter housing. Dust evacuator must be
facing down.
5. Check all hoses and air ducts. Tighten hose clamps.
Figure 4D
4.6
FUEL ____________________________________________________________________
Handle fuel with care - it is highly flammable.
Use an
approved container, the spout must fit inside the fuel filler
neck. Avoid using cans and funnels to transfer fuel.
• Fill the fuel tank to within 1 in. (25 mm) of the bottom of
the filler neck.
• Store fuel according to local, state or federal ordinances
and recommendations from your fuel supplier.
• Never overfill or allow the tank to become empty.
• Check fuel lines and clamps every 50 hours. Replace fuel
lines and clamps at the first sign of damage.
Diesel Engine:
• Use clean, fresh, #2 Diesel fuel. Minimum Cetane rating
45. Refer to Engine Manual for additional information.
Gas Engine:
• Use clean, fresh, regular grade, unleaded gasoline
minimum 85 Octane.
• Do not use hi-test gasoline or an oil-gasoline mixture.
When using blended fuel, do not use a blend with more
than 10% ethanol. Under no circumstances should you
use a blend with methanol.
4.7
FUEL SYSTEM ____________________________________________________________
Refer to Section 6.3 for specific maintenance intervals.
Before replacing any filter, thoroughly clean the filter
housing and the area around the filter. Dirt must not be
allowed to enter into fuel system.
For diesel engines, bleed the fuel system if the fuel filter and
lines have been removed, or the fuel tank has become
empty. See Engine Manual.
C
D
WARNING
Never remove the fuel cap from the fuel tank, or add fuel,
when the engine is running or while the engine is hot.
Do not smoke when handling fuel. Never fill or drain the
fuel tank indoors.
Do not spill fuel and clean spilled fuel immediately.
Never handle or store fuel containers near an open flame
or any device that may create sparks and ignite the fuel
or fuel vapors.
Be sure to reinstall and tighten fuel cap securely.
!
Summary of Contents for Greens King IV Plus
Page 28: ...7 NOTES GB 28 7 NOTES...
Page 29: ...NOTES 7 GB 29...
Page 56: ...7 NOTAS PT 28 7 NOTAS...
