12
Ioline
PLOTTING A MARKER
Before plotting a marker, turn the plotter on, load it with paper, install a pen,
and set an origin. These steps are outlined below. In most cases the design
files are sent directly from the design software to the plotter. If necessary, use
the Ioline Control Center software to send design files, adjust settings and
test plotter communication.
General Guidelines
1. Good paper loading makes good plots. Please see the following sections
about properly loading paper.
2. Do not set the plotter panel size smaller than the software frame size; the
plot will clip and the plotter may jam or tear paper.
3. Use only enough force to make a clear line. Excessive pen force might
cause misalignment problems over the range of a long plot or tear the
paper.
4. Enable the frame sensor on the 600Ae plotters to ensure accuracy over
long markers.
Installing a Pen
1. Rotate the clamp screw until there is enough room to insert the pen.
Make sure that the clamp is rotated up out of the way.
2. If using a plotter pen, slip the flange into the slot in the carriage jaw. If
using a regular pen, position the tip so that it is 1/8 inch (3 mm) off of the
platen when the jaw is in the up position. The jaw can hold any pen with
a maximum barrel diameter of 7/8 inch (22 mm). Do not use pens with red
ink.
3. Tighten the clamp screw until the pen is secure.
Power On
Turn on power to the computer and the plotter. The plotter power switch is
located next to the power cord on the back. The carriage will move to the right
end plate when the power comes on. Keep hands and loose clothing away
from moving parts. The front panel light will turn red when plotter is ready.
Paper
Ioline recommends 27 - 35 pound recycled or bond paper, 36” to 74” (91 to
188 cm) wide.
Guidelines for Plotting Pens
Refer to the table below for recommended settings for a variety of pen types.
Remember that force values are for starting reference only and require testing.
Figure 7. Installing a Pen in the Carriage Jaw.
r
e
p
a
P
n
e
P
d
e
e
p
S
e
c
r
o
F
s
m
a
r
g
s
t
n
e
m
m
o
C
-
y
a
L
r
e
p
u
S
I
M
B
t
n
e
l
a
v
i
u
q
e
r
o
™
t
a
l
F
d
n
o
b
y
t
i
l
a
u
q
h
g
i
h
e
l
y
t
s
-
P
H
t
n
i
o
p
l
l
a
b
m
u
m
i
x
a
M
0
8
-
0
6
/
p
u
n
e
p
s
m
5
1
n
e
p
s
m
5
1
s
y
a
l
e
d
n
w
o
d
"
d
n
u
o
R
®
C
I
B
c
i
t
S
t
n
i
o
p
l
l
a
b
m
u
m
i
x
a
M
0
0
2
-
0
8
1
"
d
r
o
f
n
a
S
e
i
p
r
a
h
S
m
u
m
i
x
a
M
0
0
1
-
0
7
"
e
l
y
t
s
-
P
H
p
i
t
r
e
b
i
f
m
u
i
d
e
M
0
0
1
-
0
7
_
_
_
p
i
t
c
i
t
s
a
l
P
_
_
_
_
_
_
t
o
N
d
e
d
n
e
m
m
o
c
e
R
_
_
_
p
i
t
c
i
m
a
r
e
C
_
_
_
_
_
_
t
o
N
d
e
d
n
e
m
m
o
c
e
R
_
_
_
/
k
n
i
d
i
u
q
i
L
p
i
t
l
a
t
e
M
_
_
_
_
_
_
t
o
N
d
e
d
n
e
m
m
o
c
e
R
Important Note: Do not use red ink pens.
