E
2003
CCN 99712788
&
(419) 636-4242
D
FAX (419) 633-1674
INGERSOLL-RAND COMPANY
P.O. BOX 151
D
ONE ARO CENTER
D
BRYAN, OHIO 43506Ć0151
OPERATOR’S MANUAL
PD02P-X
RELEASED:
10-1-96
REVISED:
11-12-03
(REV. L)
INCLUDING: OPERATION, INSTALLATION & MAINTENANCE
1/4” DIAPHRAGM PUMP
1:1 RATIO (NON-METALLIC)
READ THIS MANUAL CAREFULLY BEFORE INSTALLING,
OPERATING OR SERVICING THIS EQUIPMENT.
It is the responsibility of the employer to place this information in the hands of the operator. Keep for future reference.
SERVICE KITS
Refer to Service Kit Chart to match pump material with Service Kits ofĆ
fered. The X" represents a variable digit of the Model Number.
637276 Air Valve Kit.
637313ĆXX for Pump Wet End Repair (model digits 7 and 11).
637314ĆXX for Pump Rebuild (model digits 7 and 11).
PUMP DATA
Models
see Model Description Chart" for ĆXXX".
. . . . . . . .
Pump Type
NonĆMetallic Air Operated Double Diaphragm.
. . . . .
Material
see ``Model Description Chart".
. . . . . . . .
Weight
Polypropylene
4.08 lbs (1.85 kgs)
. . . .
. . . . . . . . .
Groundable Acetal
4.64 lbs (2.10 kgs)
. . . . . .
PVDF (Kynar
R
)
4.9 lbs (2.22 kgs)
. . . . . . . .
Maximum Air Inlet Pressure
100 p.s.i.g. (6.9 bar)
. . . . . . . . .
Minimum Air Inlet Pressure
20 p.s.i.g. (1.4 bar)
. . . . . . . . .
Maximum Outlet Pressure
100 p.s.i.g. (6.9 bar)
. . . . . . . . . .
Maximum Flow Rate
4.6 g.p.m. (17.4 liters)
. . . . . . . . . . . . . .
Maximum Suction Lift
20 ft. (water)
. . . . . . . . . . . . .
Maximum Output Per Cycle
0.014 gallons (53 cc's)
. . . . . . . . .
Maximum Particle Size
clean fluid only
. . . . . . . . . . . .
Maximum Temperature Limits
E.P.R. / EPDM
Ć60
_
to 280
_
F (Ć51
_
to 138
_
C)
. . . . . . . . . . .
Groundable Acetal
10
_
to 180
_
F (Ć12
_
to 82
_
C)
. . . . . . . .
Nitrile
10
_
to 180
_
F (Ć12
_
to 82
_
C)
. . . . . . . . . . . . . . . . .
Polypropylene
35
_
to 150
_
F (2
_
to 66
_
C)
. . . . . . . . . . .
PVDF (Kynar)
10
_
to 200
_
F (Ć12
_
to 93
_
C)
. . . . . . . . . . .
Santoprene
R
Ć40
_
to 225
_
F (Ć40
_
to 107
_
C)
. . . . . . . . . . .
T.F.E. (Teflon
R
)
40
_
to 225
_
F (4
_
to 107
_
C)
. . . . . . . . . .
Groundable
PD02PĆXDSĆDTX models only.
. . . . . . . . . . . . . . . .
Dimensional Data
see page 8.
. . . . . . . . . . . . . . . .
Noise Level
@ 70 p.s.i., 60 c.p.m.
59.8 db(A)
¬
. . . . .
¬
The pump sound pressure levels published here have been updated to an Equivalent Continuous Sound
Level (L
Aeq
) to meet the intent of ANSI S1.13Ć1971, CAGIĆPNEUROP S5.1 using four microphone locaĆ
tions.
NOTICE: All possible options are shown in the chart. However, certain
combinations may not be recommended, consult a representative or the
factory if you have questions concerning availability.
PD02PĆXXSĆXTX
1/4" DIAPHRAGM PUMP
MODEL DESCRIPTION CHART
PD02 P Ć X X S Ć X T X
PD02P Ć X X S Ć X T X
637313 Ć X X
Diaphragm Material
Wet End Material
FLUID SECTION SERVICE KIT SELECTION
EXAMPLE: MODEL # PD02PĆADSĆDTA
FLUID SECTION SERVICE KIT # 637313ĆDA
WET END / FLUID CAP / MANIFOLD MATERIAL
D - Groundable Acetal
K - PVDF (Kynar)
P - Polypropylene
CHECK VALVE SEAT MATERIAL
D - Groundable Acetal
K - PVDF (Kynar)
P - Polypropylene
DIAPHRAGM / O" RING MATERIAL
A - Santoprene / E.P.R.
G - Nitrile / Nitrile
T - T.F.E. (Teflon) / T.F.E. (Teflon) / Nitrile
CENTER BODY MATERIAL
P - Polypropylene
INLET / OUTLET
A - Single Inlet / Single Outlet
D - Single Inlet / Double Outlet
E - Double Inlet / Single Outlet
H - Double Inlet / Double Outlet
HARDWARE MATERIAL
S - Stainless Steel
CHECK MATERIAL
T - T.F.E. (Teflon)
