HEAT GLO CERONA-36-IFT, Installation Manual

Page: 2 / 59

Heat & Glo • CERONA-36-IFT, CERONA-42-IFT Installation Manual • 2558-980 Rev. C • 3/21
2
Safety Alert Key:
• DANGER!
Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION!
Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
Note:
The term “recommend” or “recommended” does not indicate a requirement. It is a best practice suggested by
Hearth & Home Technologies
®
.
Table of Contents
Installation Standard Work Checklist . . . . . . . . . . . . . . . . . . . . 3
1 Product Specific and Important Safety Information
A. Appliance Certification . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
B. Glass Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
C. BTU Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 4
E. Non-Combustible Materials Specification. . . . . . . . . . . . . . 4
F. Combustible Materials Specification . . . . . . . . . . . . . . . . . 4
G. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
H. California . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
I. Requirements for the Commonwealth of Massachusetts . . 5
2 Getting Started
A. Design and Installation Considerations . . . . . . . . . . . . . . . 6
B. Good Faith Wall Surface . . . . . . . . . . . . . . . . . . . . . . . . . . 6
C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . . 7
D. Inspect Appliance and Components . . . . . . . . . . . . . . . . . . 7
3 Framing and Clearances
A. Appliance/Decorative Front Dimension Diagrams . . . . . . . 8
B. Appliance Location and Clearances to Combustibles . . . 10
C. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 15
4 Termination Location and Vent Information
A. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
B. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 16
C. Vent Terminal Clearances . . . . . . . . . . . . . . . . . . . . . . . . 17
D. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
E. Adding Vent Components. . . . . . . . . . . . . . . . . . . . . . . . . 19
F. Install Support Brackets . . . . . . . . . . . . . . . . . . . . . . . . . . 20
G. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
5 Vent Clearances and Vent Framing
A. Vent Clearances to Combustibles . . . . . . . . . . . . . . . . . . 25
B. Wall Penetration Framing/Firestops . . . . . . . . . . . . . . . . . 25
C. Ceiling Firestop/Floor Penetration Framing . . . . . . . . . . . 26
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 26
6 Appliance Preparation
A. Removing Non-combustible Facing Material Assembly and
Finishing Trim . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
B. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 27
C. Installing Non-combustible Facing Material . . . . . . . . . . . 28
D. Installing Flue Restrictor . . . . . . . . . . . . . . . . . . . . . . . . . . 29
E. Prepare For Heat Management . . . . . . . . . . . . . . . . . . . . 29
7 Venting
A. Assemble Vent Sections (DVP Pipe Only) . . . . . . . . . . . 30
B. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 31
C. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 32
D. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 32
E. Vertical Termination Requirements . . . . . . . . . . . . . . . . . . 33
F. Horizontal Termination Requirements . . . . . . . . . . . . . . . 34
8 Electrical Information
A. General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
B. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
9 Gas Information
A. Fuel Conversion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
B. Gas Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
C. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 38
E. Air Shutter Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
10 Finishing
A. Facing Material . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
B. Finishing Material Options . . . . . . . . . . . . . . . . . . . . . . . . 41
C. Hearth Extension . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
D. Mantel Projections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
11 Appliance Setup
A. Remove the Shipping Materials . . . . . . . . . . . . . . . . . . . . 45
B. Clean the Appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
C. Inspect Firebox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
D. Install Media/Embers . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
E. Positioning the Logs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
F. IntelliFire™ Touch Control System Setup . . . . . . . . . . . . . 50
G. Fixed Glass Assembly Removal and Replacement . . . . . 50
H. Install Decorative Barrier . . . . . . . . . . . . . . . . . . . . . . . . . 50
12 Reference Materials
A. Vent Components Diagrams . . . . . . . . . . . . . . . . . . . . . . 51
B. Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59

= Contains updated information.
