GREAT PLAINS Yield-Pro Air-Pro YP2425A, Operator'S Manual

Page: 61 / 180

YP2425A Table of Contents Index Operating Instructions
Great Plains | 401-626M | 2019-06-11 Table of Contents Index 57
Long-Term Storage
Complete Parking steps (page 56) first.
Store the YP2425A Planter indoors if possible. Great
Plains recommends parking/storing in the raised
configuration, folded, on the parking stands and with all
lift cylinder locks installed.
1. Empty hopper (page 99).
Refer to Figure 64
2. Close the seed box or hopper clean-out door.
Clean out the air system (page 99).
3. Remove hopper or seed box (page 36).
4. Cover and seal off the opening at the top of the air
box. Leave clean-out door slightly ajar to allow any
condensed moisture to drain off.
5. Remove seed disks from meters (this is primarily to
relieve pressure on brushes). Clean disks of residue
build-up (see Caution at right). Use mild soap,
non-abrasive scrubbers, and hot or warm water. If
using sealed storage, dry disks prior to storage.
6. Close seed inlet shutters at meters (to prevent pest
entry to seed hoses). Thoroughly clean seed and
seed treatment residue from seed meters. See
“ Meter Clean-Out ” on page 100, for more
information.
7. Apply grease to exposed cylinder rods to prevent
rust.
8. Unscrew caps on end of fertilizer booms and flush
fertilizer lines (if present). Flush system with RV
antifreeze if there is any chance of freezing prior to
next implement use.
9. Empty and clean fertilizer strainers.
10. Lubricate all points listed in Maintenance to prevent
rust.
11. Clean planter of mud, dirt, excess oil and grease.
12. Inspect planter for worn or damaged parts. Make
repairs and service during off season.
13. Use spray paint to cover scratches, chips, and worn
areas on the planter to protect the metal.
14. Cover planter with a tarp if stored outside.
Storage: Fertilizer Option
The pump, strainer and manifold system require special
attention prior to storage. See “ Fertilizer System
Maintenance ” on page 113.
Figure 64
Airbox Inlet Sealed,
Clean-Out Closed
29771
 Removing the seed boxes/hoppers increases the life
of the air box seals, which are otherwise apt to be
permanently compressed if stored under load
off-season.
 Do not store optional bulk hopper outside on the
ground. Raise it on blocks, securing it in place to
prevent from falling over or blowing around by wind.
Store inside if possible.
Possible Chemical Hazard:
Seed disks will have talc and graphite residue, and may have
residues of hazardous seed treatments. Do not wash disks
where food is prepared, or where cookware or dinnerware is
washed. Wear gloves when washing disks. Avoid spray.
Although the disks are dishwasher-safe, do not wash them in
an appliance also used for food cookware or dinnerware.