20
USE AND CARE INSTRUCTIONS
Troubleshooting
WARNING
Turn gas off at source and turn Control Knobs to OFF.
Wait at least 5 minutes for gas to clear, then retry.
If your grill still fails to light, check gas supply and
connec tions.
Repeat lighting procedure. If your grill still fails to
operate, turn the gas off at source, turn the Control
Knobs to OFF, then check for the following:
If the grill fails to light :
1.
2.
3.
Obstruction in gas line
Correction:
Remove regulator hose from grill. Do not
smoke! Open gas supply for one second to clear any
obstruction from fuel line. Close off gas supply at
source and reconnect fuel line to grill.
Disconnected Electric Wires
Correction:
Inspect the Electric Ignitor (see Parts List)
found underneath the Grill Head. Connect loose
Electric wires to Junction Box and try to light the grill.
Weak AA battery
Correction:
Remove the Ignitor Cap and replace the
battery.
If the grill still does not light you may need to purge
air from the gas line or reset the regulator excess
gas flow device.
Note:
This procedure should be
done every time a new LP Gas tank is connected
to your grill.
Never
lean over the grill cooking area while lighting your
gas grill. Keep your face and body a safe distance (at least
18 inches) from the front of the grill when lighting your
grill by match.
WARNING
!
!
To purge air from your gas line and/or reset
the regulator excess gas flow device:
Turn Control Knobs to the OFF position.
Turn off the gas at the tank valve.
Disconnect regulator from LP Gas tank. For Natural
Gas, disconnect regulator from 12 ft. Natural Gas
Hose.
Let unit stand 5 minutes to allow air to purge from
Reconnect regulator to the LP Gas tank. For
Natural Gas reconnect regulator to 12 ft. Natural
Gas Hose.
Turn tank valve on SLOWLY 1/4 of a full turn. For
Natural Gas, open Shut Off valve.
Open the Grill Lid.
Push and turn the Control Knob to and hold
it in 3-5 seconds to ignite the burner.
WARNING
!
Should a FLASHBACK fire occur in or around the
Burners, follow the instructions below. Failure to
comply with these instructions could result in a fire
or explosion that could cause serious bodily injury,
death, or property damage.
!
Shut off gas supply to the gas grill.
Turn the Control Knobs to OFF position.
Open the Grill Lid.
Put out any flame with a Class B fire
extinguisher.
Ÿ
Ÿ
Ÿ
Ÿ
gas line.