LP Gas Tank Installation
13
!
WARNING
!
Never
allow children to operate your grill. Do not allow
children or pets to play near your grill. Always supervise
children and pets if they are in the vicinity of the unit.
Use of alcohol, prescription or non-prescription drugs
can impair your ability to properly assemble and safely
operate your grill.
Keep fire extinguisher readily accessible. In the event
of a oil/grease fire, do not attempt to extinguish with
water. Use type B extinguisher or smother with dirt,
sand or baking soda.
In the event of rain, turn off the burners and gas supply.
Wait for the grill to cool, and then place a cover on it.
Use your grill on a level, stable surface in an area clear
of combustible materials.
Do not leave grill unattended when in use.
Do not move the appliance when in use.
Allow the grill to cool before moving or storing.
Do not use your grill as a heater.
This grill is not intended to be installed in or on
recreational vehicles and/or boats.
The grill is not intended for commercial use.
Never use charcoal or lighter fluid in this gas grill.
CORRECT LP GAS TANK USE
LP Gas models are designed for use with a standard 20
lb. Liquid Propane Gas (LP Gas) tank (sold separately).
Never
connect your gas grill to an LP Gas tank that exceeds
this capacity. A tank of approximately 12 inches in diameter
by 18-1/2 inches high is the maximum size LP Gas tank to
use.
You must use an
"
OPD" gas tank which offers a listed
Overfill
Prevention Device.
This safety feature prevents the
tank from being overfilled which can cause a malfunction of
the LP Gas Tank, regulator, and/or grill.
Never
connect an unregulated LP gas tank to your gas
grill. The gas regulator assembly supplied with your gas
grill is adjusted to have an outlet pressure of 11" water
column (W.C.) for connection to an LP gas tank. Only use
the regulator and hose assembly supplied with your gas
grill.
Replacement regulators and hose assemblies
must be those specified by Grand Hall.
Have your LP Gas dealer check the relief valve after every
filling to ensure it remains free of defects.
Always keep LP Gas tank in upright position.
Do not subject the LP Gas tank to excessive heat.
Never store an LP Gas tank indoors. If you store your gas
grill in the garage
always
disconnect the LP Gas tank
first and store it safely outside.
LP Gas tanks must be stored outdoors in a well-ventilated
area and out of the reach of children.
Disconnected LP Gas tanks must not be stored in a
building, garage or any other enclosed area.
The regulator and hose assembly can be seen after
opening the door and must be inspected before each use
of the grill. If your regulator and hose are damaged in
any way, they must be replaced prior to using the grill
again.
Any attempt to convert the grill from one fuel type to
another is extremely hazardous and will void the warranty.
Never
light your gas grill with the lid closed or before
checking to ensure the burners are fully seated over the
gas valve orifices.
The LP Gas tank must be constructed and marked in
accordance with the Specifications for LP-Gas Cylinders of
the U.S. Department of Transportation (D.O.T.) or the
National Standard of Canada, CAN/CSA-B339, Cylinders,
Spheres and Tubes for Transportation of Dangerous
Goods; and Commission, as applicable.
The LP Gas tank must have a shutoff valve, terminating
in an LP Gas supply tank valve outlet, that is compatible
with a Type 1 tank connection device. The LP Gas tank
must also have a safety relief device that has a direct
connection with the vapor space of the tank.
The tank supply system must be arranged for vapor
withdrawal.
The LP Gas tank must have a collar to protect the tank
valve.
!
Do not store a spare LP-Gas tank under or near this
appliance.
Never fill the tank beyond 80 percent full; and
If the information in "(a)" and "(b)" is not followed
exactly, a fire causing death or serious injury may
occur.
A.
B.
C.
WARNING
!
WIND
DIRECTION
3ft.
3ft.
•
•
•
•
Use your grill at least 3 feet away from any wall or
surface.
Use your grill 3 feet away from any combustible
objects that can melt or catch fire such as vinyl or
wood siding, fences, overhangs (See Diagram Be-
low), or any other sources of ignition; including pilot
lights and live electrical appliances.
Do not use your grill under any overhead combus-
tible construction.
Never use your gas grill in a garage, porch, shed,
breezeway, or any other enclosed area.
In windy conditions, always position the front of the
grill to face oncoming wind to reduce heat and
smoke blowing in your face, and to prevent potential
hazards to yourself and the grill.
•