Generac Power Systems 004703-1, Owner'S Manual

Page: 51 / 56

49
ITEM PART NO. QTY. DESCRIPTION
1 0C2375 2 SCREW HHC M8-1.25 X 90 G8.8
2 022145 2 WASHER FLAT 5/16-M8 ZINC
3 029459 2 TENSION SPRING
4 075215 2 WASHER, SPRING CENTER
5 052858 6 NUT LOCK FL M8-1.25
6 047411 7 SCREW HHC M6-1.0 X 16 G8.8
7 022097 13 WASHER LOCK M6-1/4
8 022473 10 WASHER FLAT 1/4-M6 ZINC
9 080925 8 WASHER NYLON .404
10 0D9921 4 STANDOFF, 1/2" HEX
11 066849 2 SCREW HHTT M5-0.8 X 16
12 066386 1 ASSY, BRUSH HOLDER
13 0C9674 1 BEARING CARRIER, UP
14 0E0363H 1 STATOR ASSEMBLY (5.5 KW ONLY)
0E0364H 1 STATOR ASSEMBLY (6.5 KW ONLY)
0E0362H 1 STATOR ASSEMBLY (7.5 KW ONLY)
15 073159 1 BEARING BALL
16 077005H 1 ROTOR ASSEMBLY (5.5 KW ONLY)
077004H 1 ROTOR ASSEMBLY (6.5 KW ONLY)
073163H 1 ROTOR ASSEMBLY (7.5 KW ONLY)
17 031971 1 BEARING
18 077006 4 STUD,RV STATOR D/C
19 0C9675 1 BEARING CARRIER, LOW
20 0A5351 1 NYLON SLIDE
21 073146 2 SLIDE, NYLON
22 0C1878 2 SUPPORT, SLIDE
23 075242 4 SPRING, GEN. MOUNT
24 075237 4 WASHER, SPRING CENTER
25 090145 1 CIRCUIT BREAKER 30 X 1 (5.5 & 6.5 KW
ONLY)
0E1529 1 CIRCUIT BREAKER 35 X 1 (7.5 KW ONLY)
26 090144 1 CIRCUIT BREAKER 20 X 1 (5.5 KW ONLY)
090145 1 CIRCUIT BREAKER 30 X 1 (6.5 KW ONLY)
0E1529 1 CIRCUIT BREAKER 35 X 1 (7.5 KW ONLY)
27 025105 4 SCREW RHM 6-32 X 1/4 SIMS
28 0A9611 1 FUSE 7.5 AMP
29 032300 1 HOLDER FUSE
30 092113 1 SWITCH SPDT ON-MOM-ON
31 087798 1 SWITCH 6A SPDT
32 055440 2 SCREW HHC M5-0.8 X 25 G8.8
33 0D9377 1 PANEL, TOP CONTROL
ITEM PART NO. QTY. DESCRIPTION
34 054502 1 CIRCUIT BREAKER 3 X 1
35 031879 4 WASHER FLAT #4 ZINC
36 043182 4 WASHER LOCK M3
37 051714 4 NUT HEX M3-0.5 G8 YEL CHR
38 092234 1 ASSY POTTED RV CNTL
39 049226 5 WASHER LOCK M5
40 051716 3 NUT HEX M5-0.8 G8 YEL CHR
41 023484R 2 BUSHING SNAP
42 0D3700 1 NUT FLANGE M6-1.0 NYLOK
43 0D9378 1 PANEL, BOTTOM CONTROL
44 052619 1 SCREW HHC M5-0.8 X 20 G8.8
45 075476 2 SCREW PPHM M4-0.7 X 16
46 065795 1 RECTIFIER-BATTERY CHARGE
47 0C2174 1 RELAY 12V 25A SPST
48 092120 4 NUT LOCK TRIC M6 X 1.0 Y/ZNC
49 049721 2 SCREW HHC M6-1.0 X 35 G8.8 BLK
50 0A1658 2 WASHER LOCK SPECIAL 1/4"
51 074260-146 1 WIRE ASM GRD STD CONN.
52 049813 4 NUT HEX M6 X 1.0 G8 YEL CHR
53 023484D 1 BUSHING SNAP
54 074260-151 1 GROUND WIRE C/PNL TO STUD V-T RV
55 084867 1 RUBBER U-CHANNEL
56 043181 2 SCREW PHM M3-0.5 X 10MM
57 075210A 1 BLOCK 1 POSITION
58 022264 2 WASHER LOCK #8-M4
59 051715 2 NUT HEX M4-0.7 G8 YEL CHR
60 0C7605 2 SCREW HHC M5-0.8 X 60 G8.8
61 0F9719 1 ASY POTTED REG W/FIN
62 089047 2 SPACER .25 X .43 X .55 ST/ZNC
63 075234 1 RESISTOR WW LUG 1R 5% 25W
64 0A2053 1 SCREW HHC M6-1.0 X 65 G8.8
65 058000K 2 NUT TRIC M5 X .8
66 0D8941 1 COMPARTMENT, AIR BOX
67 029451A 2.3 FT. TAPE, 1/2" X 1/16" CLOSED CELL
68 0E0583 1 WIRE HARNESS, QP RV (GASOLINE
ONLY) (NOT SHOWN)
0E1812 1 WIRE HARNESS, QP RV (LP ONLY) (NOT
SHOWN)
69 0E1375 1 WIRE ASS'Y STARTER TO C/PNL (NOT
SHOWN)
Control Panel Drawing No. 0E1013-B
Exploded Views & Parts Lists