EZ-GO 606420-FI, Owner'S Manual And Service Manual

Page: 31 / 134

OPERATION AND SERVICE INFORMATION
Page 13
Owner’s Manual and Service Guide
Read all of Manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notes, Cautions and Warnings
Always wear safety glasses while refueling to
prevent possible eye injury from gasoline or
gasoline vapor.
When refueling, inspect the fuel cap for leaks or
breaks that could result in fuel spillage.
Do not handle fuel in an area that is not ade-
quately ventilated. Do not permit anyone to
smoke in an area where vehicles are being
fueled.
The fuel tank and cap is located under the passenger
seat (Ref Fig. 18 on page 13). Fill the tank with fresh,
clean, automotive grade, unleaded, 87 octane (minimum)
gasoline.n High altitude or heavy use/load applications
may benefit from higher octane gasoline.
Do not use gasoline which contains Methanol
Fig. 18 Fuel Tank Location
Some fuels, called oxygenated or reformulated gasoline,
are gasoline blended with alcohols or ethers. Excessive
amounts of these blends can damage the fuel system or
cause performance problems. If any undesirable operat-
ing symptoms occur, use gasoline with a lower percent-
age of alcohol or ether.
Do not overfill the fuel tank. Allow adequate space for the
expansion of gasoline. Leave at least 1" (2.5 cm) space
below bottom of filler neck.
TOWING
This vehicle is not designed to be towed.
It is recommended that the vehicle be moved by placing
the entire vehicle on a trailer, flatbed truck or other suit-
able transport.
SERVICING THE VEHICLE
To prevent severe injury or death resulting from
improper servicing techniques, observe the fol-
lowing:
Do not attempt any type of servicing opera-
tions before reading and understanding all
notes, cautions and warnings in this manu-
al.
Any servicing requiring adjustments to be
made to the powertrain while the motor is
running must be made with both drive
wheels raised.
Wear eye protection when
working on the vehicle. In par-
ticular, use care when working
around batteries, or using sol-
vents or compressed air.
To reduce the possibility of causing an elec-
trical arc, which could result in a battery
explosion, turn off all electrical loads from
the batteries before removing any heavy
gauge battery wires.
To prevent the possibility of powertrain fail-
ure, never operate vehicle at full throttle for
more than 4 - 5 seconds while vehicle is in a
‘no load’ condition.
In the best interest of both vehicle owner and servicing
dealer, carefully follow the procedures recommended in
this manual. Adequate preventative maintenance,
applied at regular intervals, is the best guarantee for
keeping the vehicle both dependable and economical.
In any product, components will fail to perform properly
as the result of normal use, age, wear or abuse.
1" Min.
(2.5 cm)
Fuel
ef Ftl 3