Evans G60MG1000THW User Manual Download Page 7

Page: 7 / 20

SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE

DANGER

• Provide adequate ventilation for toxic exhaust

gases and cooling air flow.

• Do not start or run the generator in an enclosed

area, even if doors or windows are open.

• Engines operation produces carbon monoxide, an

odorless, colorless, poison gas.

• Breathing carbon monoxide can cause nausea, fainting

or death.

CAUTION

When applying a load, do not exceed the

maximum wattage rating of the generator

when using one or more receptacles.

Also, do not exceed the amperage rating of any

receptacle.

CAUTION

Do not apply a heavy electrical load during

start period (the first two to three hours of

operation).

APPLYING LOAD

SHUTTING THE GENERATOR OFF

INITIAL START PROCEDURE

This unit has been pretested and adjusted to handle its

full capacity. When starting the generator, disconnect

all loads. Apply load only after the generator is running.

Voltage is regulated via the engine speed adjusted al the

factory for correct output. Readjusting will void warranty.

Remove entire electrical load.

Let the engine run for a few minutes with no load.

Move the engine switch to the “OFF” position.(turn the

key switch to “OFF” on the electrical start models).

Do not leave the generator until it has been completely

stopped.

Close the fuel shut off valve if the engine is to be put in

storage or transported.

If cover is used, do not install it untill the generator is

cool.

3
4
5
6

Controlled initial start helps insurance of proper engine

and generator operation. Follow engine start procedure

outlined in engine manual.

MAINTENANCE

ATTENTION: Disconnect all plugs from the panel, and

the cable of the spark plug if the motor is of electrical

starting, before any inspection for maintenance.

Before each use, review the general conditions for the

generator, review that all the pieces are complete, review

if there are damaged cables or some other condition that

2
3

4
5

can affect that the generator operates on safe way. If a

strange noise is listened to or some abnormal vibration,

turn off the generator immediately. Be sure to fix the

problem before giving the generator more use. Do not

use the equipment damaged.

Periodically inspect all the screws and bolts to check

they are in place and tight.

Keep this equipment in a clean and dry place.

For the best maintenance of the engine and any other

problem, read the engine owner’s manual.

After the engine has become cool, remove the excessive

gasoline and store it in a container, safe and approved

for that purpose.

After the first 20 hours of use of the generator drain and

replace the oil of the engine, after that the oil must be

changed every 100 working hours

HEAT SHIELD:

Inspect to ensure that all heat shields and heat deflectors

are intact and in place. Removing of these parts could

cause serious damage to the unit.

ENGINE: Carburetor Icing

During the winter months, rare atmospheric conditions

could cause an icing condition in the carburetor. If it

happens, the engine may run rough, loose power, and

may stall. Call Product Service for more information.

NOTE:

Refer to the engine manufacturer’s manual for

service and maintenance of the engine.

SERVICE AND STORAGE

QUICK STARTING TIPS FOR UNITS THAT

HAVE BEEN SITTING FOR A WHILE

If your unit has not been used for a long period of time

and it is hard to start it, try to do some of these easy

steps before calling the customers hotline.

Check the oil level.

Replace the old fuel.

Change the spark plug.

Check the fuel lines. Make sure the fuel valve is open.

Check all generator parts for integrity

Clean the carburetor. (See engine manual for service

centers)

INFREQUENT SERVICE

If the unit is used infrequently, difficult starting may result,

to eliminate hard starting, run the generator at least 30

minutes every 15 days. Also, if the unit will not be used

for some time, it is a good idea to drain the fuel from the

carburetor and gas tank.

LONG TERM STORAGE

When the generator set is not being operated or is being

stored more than one month, follow these instructions:

Replenish engine oil to upper level.

Drain gasoline from fuel tank line and carburetor.

Pour about one teaspoon of engine oil through the spark

plug hole, pull the recoil starter several times and replace

the plug. Then pull the starter until you feel piston is on

its compression stroke and leave it in that position. This

closes both the intake and exhaust valves to prevent the

inside of cylinder from rusting.

Cover the unit and store in a clean, dry place that is well

ventilated away from open flame or sparks.

NOTE: We recommend always using a fuel stabilizer.

A fuel stabilizer will minimize the formation of fuel gum

deposits during storage. The fuel stabilizer can be added

to the gasoline in the fuel tank, or into the gasoline in a

storage container.

PROPIEDAD EVANS.COM.MX PROPIEDAD EVANS.COM.MX PROPIEDAD EVANS.COM.MX

Summary of Contents for G60MG1000THW





















Search results

Summary of Contents for G60MG1000THW

Reviews:

Brands by name

Popular brands

Evans G60MG1000THW, User Manual

Search results

Summary of Contents for G60MG1000THW

Reviews:

Brands by name

Popular brands