Troubleshooting
Rev. A
5-1
5.1 General Description
This section describes procedures for isolating the failure unit in 2 levels; unit level troubleshooting and
the component level troubleshooting. You are to refer to the flowchart below to isolate the defective unit
and perform repair at the component level. Table 5-1, Table 5-2 and Table 5-3 show the coil resistance
for the CR motor and PF motor, sensor status , and Error codes and solution respectively.
Table 5-1. Coil Resistance for the Motors
Motor
Connector
No.
Test pin No.
Test method
(Set the multimeter to Ohms. Be sure to
unplug the power cable from the AC inlet
and disconnect the harnesses from the
MAIN board.)
Meter
reading
CR motor
CN14
Common pin :5,
Test pins : 1, 2
3 and 4
Place one lead to the pin 5 and the other to
each of the test pin 1, 2, 3 and 4 to check
the coil resistance of each phase of the
motor.
5
7%
(at 25
••
, per
phase)
PF motor
CN15
Pin 1 and 3 or
pin 2 and 4.
Place one lead to the Pin 1 or 2 and the
other to the 3 or 4 to check the coil
resistance of the phase 2 of the motor.
10
10 %
(at 25
••
,)
START
Troubleshooting at the unit level
Reapir of the unit
(C172 PSB/PSE board)
Repar of the unit
(C211-B MAIN board)
Repair of the unit
(M-4I60 printer mechanism)
Disassembly and adjusment
END
Figure 5-1. Troubleshooting Flowchart
Summary of Contents for 1520 - Stylus Color Inkjet Printer
