22
DOOR GLASS
(It is recommended that your dealer replace the glass if broken.)
The door glass is made of high temperature PYRO CERAMIC. The center panel is 14” x 14” inches (35.5cm x
35.5 cm). To replace the glass, unscrew and remove the four glass retainers. Remove the glass and any broken
pieces. High temperature fiberglass tape should be used around the glass. Replace the glass by screw the glass
retainers back to the frame.
FRESH AIR INTAKE
Inspect periodically to be sure that it is not clogged with any foreign materials.
EXHAUST PASSAGES
Removal of the firebox backing for bi-annual cleaning
•
Open the door by lifting the
handle, Remove the burn pot
and burn pot liner.
•
Lubricate all screws with
penetrating oil.
•
Remove the four screws that
hold the Brick liner and side
panels in place. Remove Brick
liner
•
With the tip of a flat
screwdriver, gently lift up the
side panels and remove the
side panels.
•
Pull the center panel out.
•
Vacuum thoroughly.
Installation of firebox backing:
•
Insert center panel.
•
Place the two side panels back
into the firebox and Brick liner,
reinstall the two screws on
each side.
•
Replace the glass door and
secure.
•
Clean thoroughly.
EXHAUST VENT
This vent should be cleaned every year or after two tons of pellets. We recommend contacting your dealer for
professional cleaning. To clean the vent pipe, tap lightly on the pipe to dislodge any loose ash. Open the bottom
of the ”T” to dump the ash, then vacuum as much of the ash out of the vent pipe as possible.
HEAT EXCHANGER TUBES
A handle is located under the unit top, in the center of the stove just above the door. This handle is to be pulled up
and down a few times
(ONLY WHEN THE UNIT IS COLD)
in order to clean away any fly ash that may have
collected on the heat exchanger tubes. As different types of pellets produce different amounts of ash, cleaning of
the tubes should be done on a regular basis to enable the unit to run efficiently.
POST SEASON CLEAN-UP
Once you are finished using the pellet appliance for the season, unplug the stove for added electrical protection.
It is very important that the stove be cleaned and serviced as stated above.
BRICK LINER
CENTER PANEL
SIDE PANELS X 2
Summary of Contents for EF-V EVOLUTION
Page 30: ...30 WIRING DIAGRAM...
