CYBEX 600T, Service Manual

Page: 33 / 55

Cybex 600T Treadmill Service Manual
Motor
Lead
Exit
Figure 10
c.
Place a spring and bracket over each brush. Hook the bracket in
place. See Figure 10.
13. Replace the drive motor access panels.
A. Attach each of the access panels with the two Phillips head screws.
NOTE: When installing the drive motor, rotate the motor cables toward
the top
so
that the cables don't get pinched or damaged. Align
the drive pulley with the drive belt before tightening the motor.
14. Attach the drive motor.
A. Carefully lower the drive motor in position. Be sure the four motor
pads are still in place on the base of the treadmill and the motor
doesn't contact the frame. Place the drive belt loosely around the
drive pulley.
B. Place the mounting strap around the motor over the isolator pad.
The metal mounting strap should not contact the motor. Place the
tee bar
inside the hole on the base of the treadmill and loosely
hand-tighten the nut underneath. See Figure 8.
C. Be sure that the drive pulley is aligned with the drive belt. Using a
torque wrench tighten the nut to 50 in-Ibs. Do not overtighten.
15. Re-tension the drive belt.
A. Place the drive belt onto the drive pulley.
Table of Contents
i
Read All Instructions
&
Warnings
ii
Important Safety Instructions
iv
About This Manual
Important Voltage Information . iv
FCC Compliance Information. iv
V Declaration
of Conformity
vii
Table of Contents
1
Safety
Warning Decals. . . . . . . . . .. 1-1
Caution
Decals . . . . . . . . . ..
1-2
2
Technical
. . . . . . . . . . .. 2-1
3
Preventative Maintenance
Regular Maintenance 3-1
Running Belt Maintenance.. 3-3
4
Troubleshooting
Test Mode 4-1
LED Functions. . . . . . . . . .. 4-1
Key Functions . . . . . . . . . .. 4-2
Error Codes . . . . . . . . . . . .. 4-2
Speed Sensor Adjustments. 4-3
5
Removal & Replacement
Running
Deck . . . . . . . . . . . .
5-1
Running
Belt . . . . . . . . . . . ..
5-5
Front Roller . . . . . . . . . . . . .. 5-5
Drive
Belt. . . . . . . . . . . . . . ..
5-5
Rear Roller . . . . . . . . . . . . . .. 5-6
Drive Motor . . . . . . . . . . . . .. 5-7
Motor
. . . . . . . . . . . .
5-10
Elevation Motor 5-13
Lower Control Board 5-15
Power Cables 5-16
Une Riter ' . ' 5-17
Power Switch 5-17
Power Cord Inlet 5-18
Display Board 5-18
Heart Rate Board 5-20
Lower Display Board 5-21
Polar Board 5-21
Upper Display Cable 5-22
Lower Display Cable 5-24
Display Overlays 5-25
6
Diagrams
Parts Ust . . . . . . . . . . . . . .. 6-1
Exploded View 6-3
600T Schematic 6-4
7
Customer Service
Contacting
Service . . . . . . . .
7-1
Serial Number & Voltage. . .. 7-1
Retum Material Authorization
(RMA) 7-1
Darnaged Parts 7-2
8
Index 8-1
Page 5-11