Section 07 STEERING AND FRONT SUSPENSION
Subsection 01 (STEERING AND FRONT SUSPENSION)
vmr2006-083-005_a
Remove handlebar bolts, washers and steering
clamps.
vmr2006-083-043_a
1. Handlebar bolt
2. Washer
3. Steering clamp
Move handlebar toward the front of vehicle.
Procedure for Handlebar Replacement
Use the same procedure as described in
PRO-
CEDURE IF HANDLEBAR IS NOT REPLACED
above.
However before removing handlebar
bolts, remove the following items:
– RH and LH brake levers (see
BRAKING SYS-
TEM
)
– throttle lever
– multifunction switch
– auxiliary multifunction switch and mirrors (
Eu-
ropean models
).
Remove handlebar from vehicle.
Inspection
Inspect the handlebar for damage, cracks or bend-
ing. Replace if any problem is detected.
Installation
For the installation, reverse the removal proce-
dure.
NOTE:
When torquing, the gap between lower
and upper steering clamps must be equal, on both
sides and between rear and front.
TIE-ROD
Removal
Place the vehicle on jack stands and remove ap-
propriate front wheel.
Remove cotter pin, nut and tie-rod assembly. Dis-
card cotter pin and nut.
vmr2006-083-014_a
STEERING COLUMN SIDE
1. Cotter pin
2. Nut
3. Steering column
vmr2006-083-015_a
KNUCKLE SIDE
1. Cotter pin
2. Nut
3. Knuckle
Inspection
Inspect ball joint ends for wear or looseness, if
excessive, replace.
Check rubber boots on tie-rods and ball joints. Re-
place defective part.
Check if the tie-rod is bent. Replace the tie-rod if
necessary.
vmr2006-083
185
Summary of Contents for BOMBARDIER DS250 2006
