Baja BA400, Owner'S Manual

Page: 29 / 112

Baja™ Mobility BA400
29
EN
Any electromechanical product occasionally requires some troubleshooting. However, most of the problems that
may arise can usually be solved with a bit of thought and common sense. Many of these problems occur because
the batteries are not fully charged or because the batteries are worn down and can no longer hold a charge.
DIAGNOSTIC FAULT CODES
The diagnostic fault codes for your vehicle are
designed to help you perform basic troubleshooting
quickly and easily. A diagnostic fault code will be
communicated in the event one of the conditions listed
below develops. Depending on the source of the error,
your vehicle will communicate by one of the coding
methods as follows:
1. A diagnostic fault code and error message will be
displayed on your LCD screen ( see fi gure 24 ), OR
2. A beep code will identify the condition, pause, then
repeat the beep code. The beep code will continue
to alert you in this manner until the vehicle is
turned o
ff .
V I I . B A S I C T R O U B L E S H O O T I N G
IDENTIFICATION KEY
1. FAULT CODE
2. ERROR MESSAGE
Figure 24. Fault Code Display
1
2
NOTE: Your vehicle will not run unless the fault code condition is resolved and the vehicle has been turned
o ff , then turned back on.
Figure 25. Models with LCD Control Panel
FAULT
CODE
CONDITION SOLUTION
ERROR
MESSAGE
2
Low voltage; batteries need charge immediately Charge batteries as soon as possible.
Lo BAT
3
Over voltage Unplug charger and/or turn vehicle
o ff , then back on.
HI BAT
4
Over current Turn vehicle o ff for a few minutes,
then turn vehicle back on.
HI CUR
5
Park brake fault Remove the key from the key switch,
then push the manual freewheel lever
to the drive (rearward) position and
restart your vehicle.
BRAKE
6
Throttle control lever not centered at start up Return the throttle control lever to
center position, turn vehicle o ff , then
back on.
T POT
7
Throttle control lever broken or faulted Contact your authorized dealer.
T POT
8
Motor fault Contact your authorized dealer.
MOTOR
9
Other fault Contact your authorized dealer.
OTHER