12
Charging System Warning
Icon
The Charging System Warning Icon is
designed to warn the operator if the bat-
tery charging system is not functioning.
The icon should illuminate each time the
key is turned to RUN or START, and it
should go out when the engine starts. If
the icon stays illuminated or it illumi-
nates while the engine is running, the bat-
tery is not being charged, and the
snowmobile is running on battery reserve
power only.
If the Charging System Warning Icon
illuminates, you should, as soon as possi-
ble, take the snowmobile to an authorized
Arctic Cat Snowmobile dealer for ser-
vice. If not under warranty, this service is
at the discretion and expense of the
snowmobile owner. The engine
WILL
NOT RUN
without battery power.
Oil Pressure Warning Icon
The Oil Pressure Warning Icon indicates
engine oil pressure, not the oil level;
however, if the oil level is low, it may
affect oil pressure.
The icon should illuminate each time the
ignition switch is turned to RUN or
START, and it should go out when the
engine starts. If the icon illuminates
while the engine is running, oil pressure
has been lost and the engine will auto-
matically shut off.
If oil pressure is lost, use the following
procedure to check the oil level:
1. With the engine off, remove the
engine oil level stick and wipe it
clean. Without screwing it in, set the
stick back in the oil tank. Remove it
and observe the oil level on the
stick. If the oil level is at or below
the ADD mark on the oil level stick,
add only enough recommended oil
to raise the level to the NORMAL
range. DO NOT overfill the reser-
voir with oil.
2. Open the air bleed bolt located on
the oil pump (beneath the coolant
tank) to purge air from the oil hose.
ZJ004A
NOTE: When air can no longer be
heard purging from oil pump bleed,
tighten the bleed bolt to 7.5 ft-lb.
3. Start the engine. The warning icon
should go out within five seconds.
4. If the warning icon does not go out,
shut the engine off immediately and
repeat step 2; then repeat step 3.
If the warning icon does not go out or if
the engine does not start, take the snow-
mobile to an authorized Arctic Cat Snow-
mobile dealer. If not under warranty, this
service is at the discretion and expense of
the snowmobile owner.
Diagnostic Codes
(Bearcat Z1 XT/TZ1
Models)
Diagnostic codes are activated by the
ECU and may be displayed on the read-
out screen for a number of reasons.
CAUTION
At this point, take precautionary
measures such as changing to loose
snow terrain, shutting the engine off
(allowing the engine to cool down),
and checking coolant level. If unable
to either determine or remedy the
problem, take the snowmobile to an
authorized Arctic Cat Snowmobile
dealer for service. If not under war-
ranty, this service is at the discre-
tion and expense of the snowmobile
owner.
CAUTION
Do not attempt to start the engine
with the bleed bolt open.
Summary of Contents for Bearcat 570 XT
Page 7: ...3 Snowmobile Safety Rules...
Page 67: ...63 NOTES...