2
General Information
NOTE: Some photographs and illustrations used in
this section are used for clarity purposes only and
are not designed to depict actual conditions.
Specifications
Specifications subject to change without notice.
CHASSIS
Length (Overall)
146.8 cm (57.8 in.)
Height (Overall)
96.2 cm (37.9 in.)
Width (Overall)
87.6 cm (34.5 in.)
Suspension Travel
(Front)
(Rear)
71.00 mm (2.8 in.)
73.66 mm (2.9 in.)
Tire Size
(Front)
(Rear)
AT20 x 7-8
AT19 x 8-8
Tire Inflation Pressure
0.21 kg-cm
2
(3.0 psi)
MISCELLANY
Spark Plug Type
CR7HSA
Spark Plug Gap
0.6-0.7 mm
(0.024-0.028 in.)
Dry Weight (Approx)
118 kg (260 lb) - DVX
120.2 kg (265 lb) - Utility
Gas Tank Capacity
5.7 L (1.5 U.S. gal.)
Reserve Capacity
1.3 L (0.34 U.S. gal.)
Transmission Lubricant
(Recommended)
SAE 80W-90 Hypoid
Transmission Lubricant Capacity
250 ml (8.4 fl oz)
Engine Oil Capacity
0.8 L (0.84 U.S. qt)
Gasoline (Recommended)
87 Octane Regular Unleaded
Engine Oil (Recommended)
Arctic Cat ACX All Weather
(Synthetic)
Brake Type
Front Double Drum/Rear Hydraulic
Disc w/Brake Lever Locks
Headlight
12V/35W
Brakelight
12V/5W
Starting System
Electric w/Kick Start (Emergency)
FUEL SYSTEM
Carburetor Type
Keihin PTE
Main Jet
80
Slow Jet
40
Pilot Screw Setting (turns)
1 3/8
Needle Jet
3.4/2.5
Jet Needle
NGRA-3
Idle RPM
1700
Needle Valve/Seat
1.6
Float Arm Height
10.2 mm (0.40 in.)
Throttle Cable Free-Play (at lever) 6.0 mm (0.25 in.)
IGNITION
Ignition Timing
28° BTDC (“F” Mark) @ 4000 RPM
Ignition Type
CDI
Spark Plug Cap
4725-5775 ohms
Ignition Coil
(primary)
Resistance
(secondary)
Less than 1 ohm (terminal to
terminal)
2830-3170 ohms (high tension -
plug cap removed - to ground)
MAGNETO
Timing Sensor
(peak voltage)
(resistance)
1.8-3.8 DC volts (blue/
yellow to ground)
80-160 ohms (blue/yellow
to ground)
Regulator/Rectifier
12.1-15.2 DC volts@ 3000
RPM (white to black)
CDI/Ignition Coil
(peak voltage)
190-282 DC volts (black/
yellow to green)
Stator Coil
(no load)
13.5-16.5 AC volts @3000
RPM (yellow to white)
Stator Coil Resistance
Less than 1 ohm (yellow to
white)
Choke Circuit
(voltage)
3.5-4.5 AC volts (yellow to
green/black)
ENGINE
Piston Ring End
(top)
Gap (Installed)
(2nd)
(oil)
0.15-0.30 mm
0.30-0.45 mm
0.20-0.70 mm
Piston Pin Outside Diameter (Min)
12.96 mm
Piston Pin Bore (Max)
13.03 mm
Piston Skirt/Cylinder Clearance (Max)
0.10 mm
Cylinder Head Distortion (Max)
0.05 mm
Cylinder Bore Trueness
50.00-50.05 mm
Connecting Rod (Small End Inside
Diameter) (Max)
13.06 mm
Connecting Rod (Small End Deflection)
(Max)
0.40 mm
Connecting Rod/Crankshaft Clearance
(Side to Side) (Max)
0.05 mm
Crankshaft (Runout) (Max)
0.10 mm
Camshaft Lobe Height (Intake) (Min)
26.33 mm
Camshaft Lobe Height (Exhaust) (Min)
25.65 mm
Rocker Arm to Shaft Clearance (Max)
0.10 mm
Intake Valve Stem to Guide Clearance
(Max)
0.06 mm
Exhaust Valve Stem to Guide Clearance
(Max)
0.08 mm
Valve Stem Runout
0.02 mm
Valve Face/Seat Width
0.63 mm
Valve Face Radial Runout
0.025 mm
Crankshaft Web-to-Web Distance
45.15-45.20 mm
Oil Pump Outer Rotor to Body Clearance
(Max)
0.25 mm
Oil Pump Outer to Inner Rotor Clearance
(Max)
0.20 mm
Oil Pump Rotor End Clearance (Max)
0.12 mm
V-Belt Width (Min)
16.5 mm
Centrifugal Clutch Housing (Max)
107.5 mm
Centrifugal Clutch Lining Thickness (Min) 1.0 mm
Driven Pulley Spring Free Length (Min)
154.6 mm
Roller Guide Diameter (Min)
15.4 mm
Movable Drive Face Collar (Max)
24.06 mm
Manual
Table of Contents
FOR ARCTIC CAT ATV DISCOUNT PARTS CALL 606-678-9623 OR 606-561-4983
www.mymowerparts.com