www.zodi.com
800-589-2849
Zodi options and upgrades for your Zodi Zip Shower
ZODI I.HUT
Enjoy privacy anywhere with
this self supporting hut.
Almost 4 feet wide per side!
HOT TAP HP
Hot showers in seconds! High
performance double-burner
design for all season use.
6 VOLT PUMP
6 volt replacement pump
includes 4 ft power cable and
water tight battery case.
ZODI SHOWER POLE
Enjoy hands free showering.
Adjustable height. Works with
all Zodi showers and Huts.
CAUTION - READ THIS BEFORE OPERATING SHOWER
For first use, your shower may require manual
igniting with a match to burn off oils used in
production. Your shower may also require
manual igniting with a match if igniter gets wet.
Igniter will resume proper operation after drying
out. Manual igniting hole is located above and
to the left of the gas valve knob on front of
heater. Simply insert lit match into hole and
gently open gas valve.
Water must be flowing from showerhead before
igniting propane burner. Water must always be
flowing from showerhead when propane heater
is on.
If pump is removed from water, waterflow
stops or decreases, or output water
temperature increases, point showerhead away
from body and turn heater off until proper water
flow and temperature return.
Do not use system indoors. Operating this item
in an enclosed space can kill you. Never use
this appliance indoors or in an enclosed space
such as a camper, tent, car, boat or home.
This appliance can produce carbon monoxide
which has no odor and can kill you. Use only
outdoors in well ventilated area at least 15
ft (5M) clear from flammable materials, and
completely clear of flammable liquids or vapors
when igniting & operating.
Check that all hoses are free of kinks. Most
kinks occur during storage or immediately after
use when the hoses are warm. Do not ignite
heater with kinks in pump hose or shower
hose.
Hoses must be tight and completely secured
to hose connections on heater and pump.
Once hoses are attached, they can remain on
shower. Make sure hoses are tightly secured
prior to each use. If hoses are loose, trim 2
inches from hose end and fully reattach hose to
heater and pump.
System not designed to heat water over
100°F. System not designed to heat water for
consumption.
Allow heater to cool before handling. Do not
place any items including towels, soap or
shampoo on or near heater. Keep children and
pets clear when operating. Do not leave system
unattended when operating.
Propane must be in a vertical position and
safely secured in plastic base anchored to firm
flat ground when heating. Do not connect to
remote gas supply.
This system uses a high performance heater.
When heater is turned all the way up, you may
notice hot spots on heater housing or flames
near top of system. If flames exit exhaust holes
at top of heater, turn down propane valve.
Housing color may darken with use but will
usually return after system has cooled. Note:
Discoloration is not covered by warranty.
Under certain conditions hotter water can be
obtained by turning gas valve down.
Test water temperature before use. If too hot,
turn down gas valve. If not hot enough, recycle
water as explained on previous page.
When using the optional garden hose adapter
adjust water pressure to 1 gallon from the
showerhead in 2 min 30 sec. Water pressure
higher than this will result in cooler water
temperatures.
Visually check burner for blue flame.
If flame is yellow propane tank may be low and
may need replacing.
When heater is on, small water drops caused
by condensation will drip from bottom. This is
normal, heater is NOT leaking.
If using weak batteries, it may be necessary
to apply suction to showerhead to initiate
water flow (heater must be off). Always check
that batteries are tight in battery case. If
needed, bend tabs outward to improve battery
connection. Do not mix old and new batteries.
Do not mix alkaline, carbon-zinc, or rechargeable
batteries.
Do not obstruct or restrict the flow of air for
combustion.
To prevent freeze damage to coil in cold
climates, drain all water from coil by blowing on
showerhead for 10 seconds. (Heater must be
cool.)
Remove propane cylinder from system before
and during transport and storage. Do not store
propane indoors.
The pump is a limited life item and will require
replacement with extended use. To extend
the life of the pump: remove pump from water
when not in use, rinse pump with fresh water
after each use, shake pump to remove water
after use and store pump only when completely
dry.
Pumps are not covered under warranty. For
best performance, always use new alkaline
batteries in pump and new propane in heater.
Replacement pumps can be found at your
nearest camping retailer or at www.zodi.com.
Improper use can result in injury or death. Zodi
Outback Gear not responsible for improper use.
Zodi Zip
Max Rating: <10,000 btu/hr
Gas Type: Propane 16.4 oz
Model: 3920
Patent Pending
Parts: www.zodi.com
Zodi
PO Box 4687
Park City, UT 84060
Assembled in China.
Designed in Park City, UT USA.
