![background image](http://html.mh-extra.com/html/yamaha/yzf-r125/yzf-r125_service-manual_946418336.webp)
ELECTRICAL COMPONENTS
8-65
• When charging a battery, be sure to remove
it from the vehicle. (If charging has to be
done with the battery mounted on the vehi-
cle, disconnect the negative lead from the
battery terminal.)
• To reduce the chance of sparks, do not
plug in the battery charger until the battery
charger leads are connected to the battery.
• Before removing the battery charger lead
clips from the battery terminals, be sure to
turn off the battery charger.
• Make sure the battery charger lead clips are
in full contact with the battery terminal and
that they are not shorted. A corroded bat-
tery charger lead clip may generate heat in
the contact area and a weak clip spring may
cause sparks.
• If the battery becomes hot to the touch at
any time during the charging process, dis-
connect the battery charger and let the bat-
tery cool before reconnecting it. Hot
batteries can explode!
NOTE:
Replace the battery whenever:
• battery voltage does not rise to specification or
bubbles fail to rise during charging,
• sulphation of one or more battery cells occurs
(as indicated by the battery plates turning white
or material accumulating in the bottom of the
battery cell),
• specific gravity readings after a long, slow
charge indicate that one battery cell’s charge is
lower than the rest,
• warpage or buckling of the battery plates or in-
sulators is evident.
7. Check:
• Battery breather hose and battery vent
Obstruction
→
Clean.
Damage
→
Replace.
8. Install:
• Battery
9. Connect:
• Battery breather hose “1”
CAUTION:
ECA5D71034
• When checking the battery, make sure the
battery breather hose is properly installed
and routed correctly. If the battery breather
hose is positioned so as to allow electrolyte
or hydrogen gas from the battery to contact
the frame, the vehicle and its finish may be
damaged.
• Make sure the battery breather hose is
properly routed away from the drive chain
and from below the swingarm.
10.Check:
• Battery terminals
Dirt
→
Clean with a wire brush.
Loose connection
→
Connect properly.
11.Connect:
• Battery leads
(to the battery terminals)
CAUTION:
ECA5D71042
First, connect the positive battery lead “1”,
then the negative battery lead “2”.
12.Lubricate:
• Battery terminals
13.Install:
• Rider seat
Refer to “GENERAL CHASSIS” on page 4-1.
Recommended lubricant
Dielectric grease
1
2
1
YamahaR125.COM
Содержание YZF-R125
