U.S. Products FLOODKING, Инструкция по эксплуатации и информация

Страница: 5 / 24

1/2012 A - 5 56041832 - FLOODKING
ENGLISH - A INSTRUCTIONS FOR USE
GENERAL TROUBLESHOOTING
IF THIS CHECK THIS
Pump or Vac Does Not Turn On Check the circuit breakers in the wall. If both cords were on one circuit the breaker may
have tripped.
The switches should light up when turned ON. Check the switch to make sure it is
working.
Dump Pump Not Discharging Check the circuit breakers in the wall. If both cords were on one circuit the breaker may
have tripped.
The switches should light up when turned ON. Check the switch to make sure it is
working.
Check electronic fl oat to make sure it is not obstructed and moving freely.
Vacuum Suction is Low Make sure the tank lid is closed tightly, the drain hose is closed tightly, and the recovery
hose is tight at the vac inlet hose barb and at the tool.
Check the hose for cracks.
MAINTENANCE SCHEDULE
TASK DAILY YEARLY
Inspect and clean pump inlet fi lters X
Flush tank out with clean water X
Flush dump pumps out with clean water X
Check/Clean Electronic Float X
*Check Carbon Brushes X
*Have a US Products service technician check the vacuum motor brushes once a year or after 300 operating hours.
TECHNICAL SPECIFICATIONS (as installed and tested on the unit)
MODEL
FLOODKING, FLOODKING-240
FLOODKINGPFR, FLOODKING-BE
FLOODKING-DE, FLOODKING-S
FLOODKING-SP
56381304
POWER CORD:
One, 25 ft, 12 gauge, 3-wire with hospital grade
plug
One, 25 ft, 12 gauge, 3-wire with hospital grade plug
POWER CONSUMPTION: 13 Amps, total 13 Amps, total
RECOVERY CAPACITY: 9 gallon 9 gallon
VACUUM INTAKE HOSE: 2 inch X 25 ft 2 inch X 25 ft
VACUUM MOTOR(s): Two, 3-stage Two, 3-stage
WATER LIFT/CFM: 100 inches / 170 cfm 94 inches / 170 cfm
AIR WATTS: 520 AW in operational range 520 AW in operational range
OVERFLOW PROTECTION: Electronic fl oat; auto off/on Electronic fl oat; auto off/on
DISCHARGE PUMPS: Two diaphragm bilge pumps Two diaphragm bilge pumps
DISCHARGE HOSE: One 3/4 inch X 50 ft One 3/4 inch X 50 ft
DISCHARGE RATE: 10.5 GPM 10.5 GPM
FILTER SYSTEM:
One 80 micron mesh strainer at water inlet on
recovery tank; two 60 mesh S/S fi lters in the
recovery tank; two 50 mesh S/S screens in-line
with bilge pumps One 80 micron mesh strainer at water inlet on
recovery tank; two 60 mesh S/S fi lters in the
recovery tank; two 50 mesh S/S screens in-line with
bilge pumps
WEIGHT 85 LBS 85 LBS
1/2012